|
|
|
|
|
|
| Simulation Analysis and Experiment Verification of Insulating Material-Based Photoacoustic Cell |
| CHEN Tu-nan1, 2, LI Kang1, QIU Zong-jia1, HAN Dong1, 2, ZHANG Guo-qiang1, 2* |
1. Institute of Electrical Engineering, Chinese Academy of Sciences，Beijing 100190，China
2. University of Chinese Academy of Sciences，Beijing 100049，China
|
|
|
|
|
Abstract High voltage bushing is one of the core components in a power system. Therefore, it is with significant meaning to monitor the insulation status. However, current commercial equipment for online monitoring is not suitable for bushing with special locations and small sizes. As a result, developing a detection system for bushing specifically is necessary. In-situ detection is one of the theoretically feasible ways for bushing monitoring. Compared with metal material, photoacoustic cells made of insulating material can avoid floating potentials and following partial discharge. This paper studied the feasibility of insulating material-based photoacoustic cells. First, the influence of the material on the performance of photoacoustic cells was studied, and potential problems of photoacoustic cells made of insulating material quartz were discussed. Then, using COMSOL Multiphysics, the theoretical performance of quartz photoacoustic cells was simulated from both the thermal and acoustic sides. Finally, a detection system based on quartz photoacoustic cells was established to testify to the simulation outcome. The simulation results indicated that quartz-based photoacoustic cell was as capable as the conventional brass photoacoustic cell to detect trace gas quantitatively. Besides, the detection limit of the established detection system in this word could reach the level of 0.16 μL·L-1, which could meet the relevant standard. Therefore, such insulating material-based photoacoustic cell is with the potential for in-situ detection of bushing.
|
|
Received: 2022-07-04
Accepted: 2023-06-04
|
|
|
|
Corresponding Authors:
ZHANG Guo-qiang
E-mail: zhanggqi@mail.iee.ac.cn
|
|
[1] XIAO Tian-wei, ZHANG Qiang, HUANG Yan-guang, et al(肖天为, 张 强, 黄炎光, 等). Power System Technology(电网技术)，2015，39(6)：1719.
[2] JI Sheng-chang, ZHONG Li-peng, LIU Kai, et al(汲胜昌, 钟理鹏, 刘 凯, 等). Proceedings of the CSEE(中国电机工程学报)，2015，35(9)：2318.
[3] Chen Tunan, Ma Fengxiang, Zhao Yue, et al. Optik (Stuttg), 2021, 243: 167440.
[4] Chen Tunan, Ma Fengxiang, Zhao Yue, et al. Sens. Rev., 2022, 42(1): 70.
[5] Sergio Bustamante, Mario Manana, Alberto Arroyo, et al. Sensors (Switzerland), 2019, 19: 4057.
[6] MA Feng-xiang, TIAN Yu, CHEN Ke, et al(马凤翔, 田 宇, 陈 珂, 等). Acta Optica Sinica(光学学报)，2020，40(7)：0730003.
[7] Rück T, Bierl R, Matysik F M. Sensors Actuators A: Phys., 2017, 263: 501.
[8] CHENG Gang, CAO Yuan, LIU Kun，et al(程 刚, 曹 渊, 刘 锟, 等). Acta Physica Sinica(物理学报)，2019，68(7)：074202.
[9] Berggren M, Bernland A, Noreland D. J. Comput. Phys., 2018, 371: 633.
[10] CHEN Wei-gen, LIU Bing-jie, ZHOU Heng-yi, et al(陈伟根, 刘冰洁, 周恒逸, 等). Transactions of China Eletrotechnical Society(电工技术学报)，2010，25(11)：15.
[11] TANG Ju, FAN Min, QIU Yin-jun, et al(唐 炬, 范 敏, 裘吟君, 等). High Voltage Engineering(高电压技术)，2012，38(11)：2919.
[12] CHENG Gang, CAO Ya-nan, TIAN Xing, et al(程 刚, 曹亚南, 田 兴, 等). Spectroscopy and Spectral Analysis(光谱学与光谱分析)，2020，40(8)：2345.
[13] State Grid(国家电网公司). Technical Specification for Energized Device of Electrical Equipment Part 4: Technical Specification for Energized Device of Gased Dissolved in Oil (Photoacoustic Spectrometry Method)(电力设备带电检测仪器技术规范第4-2 部分：油中溶解气体分析带电检测仪器技术规范（光声光谱法）), 2015.
|
| [1] |
ZHENG Hong-quan, DAI Jing-min*. Research Development of the Application of Photoacoustic Spectroscopy in Measurement of Trace Gas Concentration[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2024, 44(01): 1-14. |
| [2] |
XU Qiu-yi1, 3, 4, ZHU Wen-yue3, 4, CHEN Jie2, 3, 4, LIU Qiang3, 4 *, ZHENG Jian-jie3, 4, YANG Tao2, 3, 4, YANG Teng-fei2, 3, 4. Calibration Method of Aerosol Absorption Coefficient Based on
Photoacoustic Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2024, 44(01): 88-94. |
| [3] |
FU Wen-xiang, DONG Li-qiang, YANG Liu*. Research Progress on Detection of Chemical Warfare Agent Simulants and Toxic Gases by Photoacoustic Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(12): 3653-3658. |
| [4] |
CHENG Gang1, CAO Ya-nan1, TIAN Xing1, CAO Yuan2, LIU Kun2. Simulation of Airflow Performance and Parameter Optimization of
Photoacoustic Cell Based on Orthogonal Test[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(12): 3899-3905. |
| [5] |
JIN Hua-wei1, 2, 3, WANG Hao-wei1, 2, LUO Ping1, 2, FANG Lei1, 2. Simulation Design and Performance Analysis of Two-Stage Buffer
Photoacoustic Cell[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(08): 2375-2380. |
| [6] |
ZHANG Yu-feng1, WU Yu-ling2, WU Yuan-qing1*, JIA Hui2, LIU Wen-hao2, DAI Jing-min3. Effect of Surface Structure on Emissivity of Area Blackbody[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(02): 389-393. |
| [7] |
LI Zhen-gang1, 2, SI Gan-shang1, 2, NING Zhi-qiang1, 2, LIU Jia-xiang1, FANG Yong-hua1, 2*, CHENG Zhen1, 2, SI Bei-bei1, 2, YANG Chang-ping1, 2. Research on Long Optical Path and Resonant Carbon Dioxide Gas
Photoacoustic Sensor[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(01): 43-49. |
| [8] |
FAN Yuan-chao, CHEN Xiao-jing*, HUANG Guang-zao, YUAN Lei-ming, SHI Wen, CHEN Xi. Evaluation of Aging State of Wire Insulation Materials Based on
Raman Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2022, 42(10): 3161-3167. |
| [9] |
WANG Qi, WANG Shi-chao, LIU Tai-yu, CHEN Zi-qiang. Research Progress of Multi-Component Gas Detection by Photoacoustic Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2022, 42(01): 1-8. |
| [10] |
REN Zhong1, 2*, LIU Tao1, LIU Guo-dong1, 2. Classification and Identification of Real or Fake Blood Based on OPO Pulsed Laser Induced Photoacoustic Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(09): 2734-2741. |
| [11] |
WAN Liu-jie1, 2, ZHEN Chao3, QIU Zong-jia1, LI Kang1, MA Feng-xiang3, HAN Dong1, 2, ZHANG Guo-qiang1, 2*. Research of High Precision Photoacoustic Second Harmonic Detection Technology Based on FFT Filter[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2020, 40(10): 2996-3001. |
| [12] |
CHEN Jie1, 2, 3, QIAN Xian-mei1, 3, LIU Qiang1, 3*, ZHENG Jian-jie1, 2, 3, ZHU Wen-yue1, 3, LI Xue-bin1, 3. Research on Optical Absorption Characteristics of Atmospheric Aerosols at 1 064 nm Wavelength[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2020, 40(10): 2989-2995. |
| [13] |
XIE Ying-chao1,2, WANG Rui-feng1,2, CAO Yuan1,2, LIU Kun1*, GAO Xiao-ming1,2. Research on Detecting CO2 With Off-Beam Quartz-Enhanced Photoacoustic Spectroscopy at 2.004 μm[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2020, 40(09): 2664-2669. |
| [14] |
CHENG Gang1, CAO Ya-nan1, TIAN Xing1, CAO Yuan2, LIU Kun2*. Influence of Photoacoustic Cell Geometrical Shape on the Performance of Photoacoustic Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2020, 40(08): 2345-2351. |
| [15] |
WANG Qiao-yun, YIN Xiang-yu, YANG Lei, XING Ling-yu. Geometrical Optimization of Resonant Ellipsoidal Photoacoustic Cell in Photoacoustic Spectroscopy System[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2020, 40(05): 1351-1355. |
|
|
|
|
