|
|
|
|
|
|
A LIBS Spectral Self-Absorption Correction Method Using Voigt Profile Fitting for the Application of Magnesium Analysis in Phosphorus Ore |
ZHANG Peng1, 2, 3, 4, SUN Lan-xiang1, 2, 3*, YU Hai-bin1, 2, 3, QI Li-feng1, 2, 3, ZENG Peng1, 2, 3 |
1. Shenyang Institute of Automation, Chinese Academy of Sciences, Shenyang 110016, China
2. Institutes for Robotics and Intelligent Manufacturing, Chinese Academy of Sciences, Shenyang 110016, China
3. Key Laboratory of Network Control System, Chinese Academy of Sciences, Shenyang 110016, China
4. University of Chinese Academy of Sciences,Beijing 100049, China |
|
|
Abstract The concentration of MgO is one of the most important parameters in the phosphate ore flotation. The fast detection of the concentration of MgO has great significance for the optimization of the flotation, the improvement of the efficiency and the reduction of the cost. Therefore, LIBS (Laser Induced Breakdown Spectroscopy) is introduced into the analysis of Mg in phosphate. But the common used strong lines of Mg (Mg Ⅱ 279.6 nm, Mg Ⅱ 280.3 nm, Mg Ⅰ 285.2 nm) are resonance lines in LIBS analysis. For the effect of the self-absorption, the spectral intensity of the resonance line is lower than the theoretical value, and this intensity reduction will reduce the accuracy of the analysis. In this work, a method based on an approximate function of Voigt profile was proposed. Firstly, simplified the Voigt profile function with the approximate function; secondly, determined the center of the spectral line and the full width at half maximum (FWHM) under ideal conditions with the low concentration samples; then, determined the wing area for fitting by calculating the slope of the spectral area near the spectral peak; finally, obtained the fitting profile closer to the theoretical one, by fitting the approximate function with the wing area selected above. In the application of the quantitative analysis of Mg in phosphate ore, the internal standard method was used forthe calibration. The fitting spectral areas of Mg Ⅰ 285.2 nm and Si Ⅰ 288.2 nm were chosen as the analytical line intensity and the reference line intensity, respectively. Comparing the internal standard method without fitting, the determination coefficient (R2) with the proposed method was improved from 0.923 to 0.998; the root-mean-square error (RMSE) and the average relative error (ARE) were reduced from 0.96 and 38.65% to 0.16 and 2.79%, respectively. The calibration results proved that with the proposed method, the measurement accuracy can be improved significantly for the application of magnesium analysis in phosphorus ore.
|
Received: 2018-11-12
Accepted: 2019-03-20
|
|
Corresponding Authors:
SUN Lan-xiang
E-mail: sunlanxiang@sia.cn
|
|
[1] Afgan M S, Hou Z Y, Wang Z. Journal of Analytical Atomic Spectrometry, 2017, 32(10): 1905.
[2] WANG Qian-qian, ZHAO Yu, LU Xiao-gang, et al(王茜蒨, 赵 宇, 卢小刚, 等). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2017, 37(8): 2430.
[3] Shen M, Li C M, Na D, et al. Journal of Analytical Atomic Spectrometry, 2018, 33(4): 658.
[4] Matsumoto A, Ohba H, Toshimitsu M, et al. Spectrochimica Acta Part B: Atomic Spectroscopy, 2018, 142: 37.
[5] Xin Y, Sun L X, Yang Z J, et al. Frontiers of Physics, 2016, 11(5):1.
[6] Costa V C, De Babos D V, De Aquino F W B, et al. Food Analytical Methods, 2017, 11(7): 1886.
[7] Rehan I, Rehan K, Sultana S, et al. Applied Physics B, 2018, 124(5):76.
[8] LUAN Ya-ge, LU Cui-ping, HU Hai-ying, et al(栾亚阁, 鲁翠萍, 胡海瀛, 等). Applied Laser(应用激光), 2015, (6): 708.
[9] Zhang P, Sun L X, Yu H B, et al. Journal of Analytical Atomic Spectrometry, 2017, 32(12): 2371.
[10] Sabri N M, Haider Z, Tufail K, et al. Physics of Plasmas, 2018, 25(7): 9.
[11] Zhao F G, Zhang Y, Zhang L, et al. Acta Physica Sinica, 2018, 67(16): 5.
[12] Tang Y, Guo L, Tang S, et al. Appl. Opt., 2018, 57(22): 6451.
[13] YIN Zeng-qian, WU Chen, GONG Wan-yu,et al(尹增谦, 武 臣, 宫琬钰, 等). Acta Physica Sinica(物理学报), 2013, (12): 212.
[14] LIU Ming-hui, DONG Zuo-ren, XIN Guo-feng, et al(刘铭晖, 董作人, 辛国锋,等). Chinese Journal of Lasers(中国激光), 2017, (5): 255.
[15] Wertheim G K, Butler M A, West K W, et al. Review of Scientific Instruments, 1974, 45(11): 1369. |
[1] |
LIU Jia1, 2, GUO Fei-fei2, YU Lei2, CUI Fei-peng2, ZHAO Ying2, HAN Bing2, SHEN Xue-jing1, 2, WANG Hai-zhou1, 2*. Quantitative Characterization of Components in Neodymium Iron Boron Permanent Magnets by Laser Induced Breakdown Spectroscopy (LIBS)[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2024, 44(01): 141-147. |
[2] |
LIU Hao-dong1, 2, JIANG Xi-quan1, 2, NIU Hao1, 2, LIU Yu-bo1, LI Hui2, LIU Yuan2, Wei Zhang2, LI Lu-yan1, CHEN Ting1,ZHAO Yan-jie1*,NI Jia-sheng2*. Quantitative Analysis of Ethanol Based on Laser Raman Spectroscopy Normalization Method[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(12): 3820-3825. |
[3] |
YANG Wen-feng1, LIN De-hui1, CAO Yu2, QIAN Zi-ran1, LI Shao-long1, ZHU De-hua2, LI Guo1, ZHANG Sai1. Study on LIBS Online Monitoring of Aircraft Skin Laser Layered Paint Removal Based on PCA-SVM[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(12): 3891-3898. |
[4] |
LIN Hong-jian1, ZHAI Juan1*, LAI Wan-chang1, ZENG Chen-hao1, 2, ZHAO Zi-qi1, SHI Jie1, ZHOU Jin-ge1. Determination of Mn, Co, Ni in Ternary Cathode Materials With
Homologous Correction EDXRF Analysis[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(11): 3436-3444. |
[5] |
HUANG Li, MA Rui-jun*, CHEN Yu*, CAI Xiang, YAN Zhen-feng, TANG Hao, LI Yan-fen. Experimental Study on Rapid Detection of Various Organophosphorus Pesticides in Water by UV-Vis Spectroscopy and Parallel Factor Analysis[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(11): 3452-3460. |
[6] |
LI Zhong-bing1, 2, JIANG Chuan-dong2, LIANG Hai-bo3, DUAN Hong-ming2, PANG Wei2. Rough and Fine Selection Strategy Binary Gray Wolf Optimization
Algorithm for Infrared Spectral Feature Selection[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(10): 3067-3074. |
[7] |
SUN Cheng-yu1, JIAO Long1*, YAN Na-ying1, YAN Chun-hua1, QU Le2, ZHANG Sheng-rui3, MA Ling1. Identification of Salvia Miltiorrhiza From Different Origins by Laser
Induced Breakdown Spectroscopy Combined with Artificial Neural
Network[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(10): 3098-3104. |
[8] |
LIU Shu1, JIN Yue1, 2, SU Piao1, 2, MIN Hong1, AN Ya-rui2, WU Xiao-hong1*. Determination of Calcium, Magnesium, Aluminium and Silicon Content in Iron Ore Using Laser-Induced Breakdown Spectroscopy Assisted by Variable Importance-Back Propagation Artificial Neural Networks[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(10): 3132-3142. |
[9] |
KONG De-ming1, LIU Ya-ru1, DU Ya-xin2, CUI Yao-yao2. Oil Film Thickness Detection Based on IRF-IVSO Wavelength Optimization Combined With LIF Technology[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(09): 2811-2817. |
[10] |
ZHAO Yu-wen1, ZHANG Ze-shuai1, ZHU Xiao-ying1, WANG Hai-xia1, 2*, LI Zheng1, 2, LU Hong-wei3, XI Meng3. Application Strategies of Surface-Enhanced Raman Spectroscopy in Simultaneous Detection of Multiple Pathogens[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2012-2018. |
[11] |
LI Chang-ming1, CHEN An-min2*, GAO Xun3*, JIN Ming-xing2. Spatially Resolved Laser-Induced Plasma Spectroscopy Under Different Sample Temperatures[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2032-2036. |
[12] |
ZHAO Yang1, ZHANG Lei2, 3*, CHENG Nian-kai4, YIN Wang-bao2, 3*, HOU Jia-jia5, BAI Cheng-hua1. Research on Space-Time Evolutionary Mechanisms of Species Distribution in Laser Induced Binary Plasma[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2067-2073. |
[13] |
WANG Bin1, 2, ZHENG Shao-feng2, GAN Jiu-lin1, LIU Shu3, LI Wei-cai2, YANG Zhong-min1, SONG Wu-yuan4*. Plastic Reference Material (PRM) Combined With Partial Least Square (PLS) in Laser-Induced Breakdown Spectroscopy (LIBS) in the Field of Quantitative Elemental Analysis[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2124-2131. |
[14] |
CHENG Xiao-xiang1, WU Na2, LIU Wei2*, WANG Ke-qing2, LI Chen-yuan1, CHEN Kun-long1, LI Yan-xiang1*. Research on Quantitative Model of Corrosion Products of Iron Artefacts Based on Raman Spectroscopic Imaging[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2166-2173. |
[15] |
HU Meng-ying1, 2, ZHANG Peng-peng1, 2, LIU Bin1, 2, DU Xue-miao1, 2, ZHANG Ling-huo1, 2, XU Jin-li1, 2*, BAI Jin-feng1, 2. Determination of Si, Al, Fe, K in Soil by High Pressure Pelletised Sample and Laser-Induced Breakdown Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2174-2180. |
|
|
|
|