Ni3V2O8催化性能与X射线光电子能谱分析

Abstract
References
Related Citation (15)

Download: PDF (1769 KB)
Export: BibTeX | EndNote (RIS)

Abstract Ni₃V₂O₈ catalyst was prepared by oxalate co-precipitation method with microwave heating in this paper. In order to study the relationship between the catalytic performance and the surface species, the catalyst was characterized by XRD, BET, H₂-TPR, XPS, TEM and conductivity measurement. The surface property of Ni₃V₂O₈ was studied by XPS and the catalytic performance of the oxidative dehydrogenation of propane to propylene was also investigated. The results of XRD showed that pure Ni₃V₂O₈ with nice structure was obtained. TEM experiments results demonstrated that the prepared Ni₃V₂O₈ catalyst at 700 ℃ calcination showed uniform particle with the mean particle size of 30 nm. The surface area of the catalyst was 8.623 m²·g^-1. The diagram of the relationship between electrical conductivity and oxygen partial pressure of Ni₃V₂O₈ showed dσ/dP_O₂＞0, implying that Ni₃V₂O₈ catalyst was a p-type semiconductor. H₂-TPR results showed that only one unsymmetrical reduction peak appeared at 663.5 ℃ within 300-900 ℃ region over Ni₃V₂O₈ catalyst and no obvious shoulder peak was observed. It could also be found that the ratio of non complete reduction oxygen species was about 33.59%(O^- 27.55%, O^2-₂ 6.04%) from the O(1s) XPS result and more V4+ species existed on the Ni₃V₂O₈ catalyst surface. The TPR and XPS results illustrated that the transformation of the lattice oxygen to non-complete reduction oxygen in Ni₃V₂O₈ catalyst might promote the oxidation-reduction reaction between different valence vanadium and promoted the oxygen vacancy formation. This then led to abundant non-complete reduction oxygen O^- and V4+ species formation on the surface of Ni₃V₂O₈ catalyst. The active result of oxidative dehydrogenation of propane to propylene showed that the 60.02% propylene selectivity could be reached at 18.60% propane conversion. Compared with the reported results over the coexistent NiO and Ni₃V₂O₈ system from the literature, pure Ni₃V₂O₈ catalyst system in this present paper showed higher propylene selectivity than the coexistent NiO and Ni₃V₂O₈ system under the same propane conversion condition, suggesting that the performance of propane to propene is correlated to the oxidation-reduction of V⁴⁺/V⁵⁺ couple and non complete reduction oxygen species(O^- or O^2-₂). This result further illustrated that Ni₃V₂O₈ was active phase for oxidative dehydrogenation of propane to propylene. Combining the active and characterization results, it was found that catalytic activity was correlated to the surface non-complete reduction O^- and V⁴⁺ species, which was beneficial to improving the propylene selectivity.

Key words：Ni₃V₂O₈;X-ray photoelectron spectroscopy (XPS);Oxygen species;Oxidative dehydrogenation (ODH);p-type semiconductor

Received: 2007-01-12 Accepted: 2007-04-16

ZTFLH:

O657.6

Corresponding Authors: ZHAORIGETU Bao E-mail: zrgt@imnu.edu.cn

Cite this article:

XU Ai-ju,ZHAORIGETU Bao,JIA Mei-lin, et al. Study on Performance of Ni₃V₂O₈ Catalyst and Analysis of X-Ray Photoelectron Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2007, 27(10): 2134-2138.

URL:

https://www.gpxygpfx.com/EN/Y2007/V27/I10/2134

[1] Blasco T, López Nieto J M. Appl. Catal. A: Gen, 1997, 157(1-2): 117.
[2] Chao Z S, Ruckenstein E. Catal. Lett., 2003, 88(3-4): 147.
[3] Chaar M A, Patel D, Kung M C, Kung H H. J. Catal., 1987, 105(2): 483.
[4] LIU Rui, WANG Xin-ping, JIA Cui-ying, et al(刘睿, 王新平, 贾翠英, 等). Chin. J. Catal.(催化学报)，2005, 26(8): 650.
[5] Chaar M A, Patel D, Kung H H. J. Catal., 1988, 109(2): 463.
[6] FANG Zhi-min, WENG Wei-zheng, WAN Hui-lin, et al(方智敏, 翁维正, 万惠霖, 等). J. Xiamen University(厦门大学学报), 1998, 37(4): 525.
[7] Zhaorigetu B, Li W Zh, Kieffer R, et al. Reaction Kinetics and Catalysis Lett., 2002, 75(2): 275.
[8] Zhaorigetu B, Li W Zh, Xu H Y. Catal. Lett., 2004, 94(1-2): 125.
[9] Oganowski W, Hanuza J, Kepiski L. Appl. Catal. A: Gen, 1998, 171(1): 145.
[10] Mingos D M P, Baghurst D R. Chem. Soc. Rev., 1991, 20(1): 1.
[11] WU Hua-qiang, SHAO Ming-wang, GU Jia-shan, et al(吴华强, 邵名望, 顾家山, 等). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2005, 25(6): 949.
[12] CHEN Tong, LI Wen-zhao, YU Chun-ying(陈铜, 李文钊, 于春英). Chin. J. Catal.(催化学报), 1997, 18(2): 160.
[13] Yu Chuying, Li Wenzhao, Feng Wenju, et al. Studies in Surface Sci. and Catalysis, 1993, 75: 1119.
[14] Xu Q, Chen W, Yuan R Z. Chin. J. Mater. Sci. Technol., 2001, 17(5): 535.
[15] YANG He, ZHANG Zheng-ye, LI Sheng-hua, et al(杨鹤, 张正业, 李生华, 等). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2005, 25(6): 945.
[16] WU Xiao-li, YUE Tao, LU Rong-rong, et al(吴小利, 岳涛, 陆荣荣, 等). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2005, 25(10): 1595.
[17] YUAN Huan-xin, OUYANG Jian-ming(袁欢欣, 欧阳健明). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2007, 27(2): 395.
[18] Carrazan S R G, Peres C, Bernard J P, et al. J. Catal., 1996, 158(2): 452.
[19] Herrmann J M, Vernoux P, Béré K E, Abon M. J. Catal., 1997, 167(1): 106.
[20] YU Chun-ying, LI Wen-zhao, QI Ai-hua(于春英, 李文钊, 齐爱华). Chin. J. Catalysis(催化学报), 1994, 15(5): 338.