|
|
|
|
|
|
| A Study on Emission Spectral Diagnosis of Ar/CH4 Plasma Jet |
| LI Zheng-kai1, CHEN Lei1*, YANG Cong1, SONG Peng2, 3, ZENG Wen1, LIU Ai-guo1, PANG Jun-yi1 |
1. Aerospace Engineering Institute, Shenyang Aerospace University, Shenyang 110136, China
2. College of Mechanical and Electronic Engineering, Dalian Minzu University, Dalian 116600, China
3. Institute of Internal Combustion Engine, Dalian University of Technology, Dalian 116024, China |
|
|
|
|
Abstract In order to have abetter understanding on the discharge mechanism of Ar/CH4 plasma jet and the state of its internal electrons under atmospheric pressure, a stable Ar/CH4 plasma jet was produced in the atmosphere through a self-designed needle-ring Dielectric Barrier Discharge structure with a discharge frequency of 10kHz, and the plasma jet was diagnosed by emission spectroscopy. The discharge phenomenon of Ar/CH4 plasma jet and the types of active particles inside were analyzed under atmospheric conditions. The effects of different argon-methane volume flow ratios and different peak voltages on the electron excitation temperature, electron density and concentration of CH group active particles in atmospheric pressure Ar/CH4 plasma jet were emphasis studied. The results show that the Ar/CH4 plasma jet is light blue under atmospheric pressure, and filamentous burrs can be observed on the edge of the jet. A harsh ionizing sound accompanies the discharge, and the shape of the jet tip fluctuates greatly; The main active particles in Ar/CH4 plasma jet at atmospheric pressure are CH group, C atom, CⅡ, CⅢ, CⅣ, ArⅠ and ArⅡ. Among them, the spectral lines of carbon-containing particles are mainly concentrated between 400 and 600 nm, and the spectral lines of ArⅠ and ArⅡ are distributed between 680 and 800 nm; It can be found that the concentration of the CH group increases with the increase of the peak voltage, however, the concentration of CH group decreases with the increase of the volume flow ratio of Ar/CH4. At the same time, the concentration of C atoms in the Ar/CH4 plasma jet increases. This means that the increase of the volume flow rate accelerates C—H fracture in the Ar/CH4 plasma jet. Therefore, it can be seen that increasing of the peak voltage and Ar/CH4 volume flow ratio can significantly accelerate the dehydrogenation efficiency of methane molecules, but increasing the Ar/CH4 volume flow ratio dehydrogenation effect is more obvious. Four ArⅠ lines was selected to calculate the electron excitation temperature under different operating conditions. The electron excitation temperature of Ar/CH4 plasma jet is between 6 000 and 12 000 K, and it shows an upward trend with the increase of the peak voltage and the volume flow rate of Ar/CH4; The electron density of the Ar/CH4 plasma jet was calculated based on the Stark broadening mechanism, the magnitude of electron density can reach 1017 cm-3, and plasma jet electron density can be significantly improved by increasing the volume flow ratio of Ar/CH4 and peak voltage. The exploration of these parameters is of great significance to the study of atmospheric pressure plasma jets.
|
|
Received: 2020-05-01
Accepted: 2020-08-08
|
|
|
|
Corresponding Authors:
CHEN Lei
E-mail: chenleisau@126.com
|
|
[1] Xie Q, Lin H F, Zhang S, et al. Plasma Science and Technol., 2018, 20(2): 025504.
[2] ZENG Ke, LONG Xue-ming, LIU Bing(曾 科，龙学明，刘 兵). Transactions of Csice(内燃机学报), 2003, (1): 45.
[3] HE Li-ming, CHEN Gao-cheng, ZHAO Bing-bing, et al(何立明，陈高成，赵兵兵，等). High Voltage Engineering(高电压技术), 2018, 44(3): 856.
[4] LU Xin-pei(卢新培). High Voltage Engineering(高电压技术), 2011, 37(6): 1416.
[5] Rie K T, Menthe E, Wohle J. Surfacce and Coating Technology, 1998, 98(1-3): 1192.
[6] Srivastava N, Wang C. Plasma Science and Technol., 2019, 21(11): 115401.
[7] SONG Zhen-xing, HE Li-ming, ZHANG Peng, et al(宋振兴，何立明，张 鹏，等). High Voltage Engineering(高电压技术), 2012, 38(7)：1758.
[8] SONG Peng, ZHANG Wei, CHEN Lei, et al(宋 鹏，张 维，陈 雷，等). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2019, 39(2): 410.
[9] Chen L, Ma M W, Li M, et al. Plasma Science and Technol., 2011, 13(6): 689.
[10] YANG Meng, XUE Jiao, LI Ming, et al(杨 萌，薛 娇，李 铭，等). Chinese Journal of Analytical Chemistry（分析化学）, 2012, 40(8): 1164. |
| [1] |
TIAN Fu-chao1, CHEN Lei2*, PEI Huan2, BAI Jie-qi1, ZENG Wen2. Study of Factors Influencing the Length of Argon Plasma Jets at
Atmospheric Pressure With Needle Ring Electrodes[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(12): 3682-3689. |
| [2] |
LIU Pan1, 2, 3, DU Mi-fang1*, LI Bin1, LI Jing-bin1, ZENG Lei1, LIU Guo-yuan1, ZHANG Xin-yao1, 4, ZHA Xiao-qin1, 4. Determination of Trace Tellurium Content in Aluminium Alloy by
Inductively Coupled Plasma-Atomic Emission Spectrometry Method[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(10): 3125-3131. |
| [3] |
TIAN Fu-chao1, CHEN Lei2*, PEI Huan2, BAI Jie-qi1, ZENG Wen2. Diagnosis of Emission Spectroscopy of Helium, Methane and Air Plasma Jets at Atmospheric Pressure[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(09): 2694-2698. |
| [4] |
LI Chang-ming1, CHEN An-min2*, GAO Xun3*, JIN Ming-xing2. Spatially Resolved Laser-Induced Plasma Spectroscopy Under Different Sample Temperatures[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2032-2036. |
| [5] |
WANG Wei, WANG Yong-gang*, WU Zhong-hang, RAO Jun-feng, JIANG Song, LI Zi. Study on Spectral Characteristics of Pulsed Argon Vacuum Dielectric
Barrier Discharge[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(02): 455-459. |
| [6] |
LI Ru, YANG Xin, XING Qian-yun, ZHANG Yu. Emission Spectroscopy Study of Remote Ar Plasma[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(02): 394-400. |
| [7] |
YANG Kun, CHEN Lei*, CHENG Fan-chong, PEI Huan, LIU Gui-ming, WANG Bao-huai, ZENG Wen. Emission Spectroscopy Diagnosis of Air Gliding Arc Plasma Under
Atmospheric Pressure Condition[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2022, 42(10): 3006-3011. |
| [8] |
LEI Bing-ying1, 2, XU Bo-ping1, 2, WANG Yi-shan1, 2, ZHU Xiang-ping1, 2, DUAN Yi-xiang3, ZHAO Wei1, 2, TANG Jie1*. Investigation of the Spectral Characteristics of Laser-Induced Plasma for Non-Flat Samples[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2022, 42(10): 3024-3030. |
| [9] |
PEI Huan1, CHEN Lei1*, WANG Si-yuan2, YANG Kun1, SONG Peng2. Flame Spectrum and Active Particles Analysis of the Effect of Dielectric Barrier Discharge Induced on Gliding Arc Discharge With the Mixture of Methane-Air-Ar Within A Dual Mode Discharge[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2022, 42(07): 2007-2012. |
| [10] |
YANG Jin-chuan1, 2, AN Jing-long1, 2, LI Cong3, ZHU Wen-chao3*, HUANG Bang-dou4*, ZHANG Cheng4, 5, SHAO Tao4, 5. Study on Detecting Method of Toxic Agent Containing Phosphorus
(Simulation Agent) by Optical Emission Spectroscopy of
Atmospheric Pressure Low-Temperature Plasma[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2022, 42(06): 1728-1734. |
| [11] |
GONG Zheng1, LIN Jing-jun2*, LIN Xiao-mei3*, HUANG Yu-tao1. Effect of Heating and Cooling on the Characteristic Lines of Al During Melting[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2022, 42(02): 598-602. |
| [12] |
LI Xue, LIN Jing-song, GUO Yi-tong, HUO Wei-gang*, WANG Yu-xin, XIA Yang. Studies on the Electrical and Spectrum Characteristics in Atmospheric Dielectric Barrier Discharge in Helium-Argon Mixture[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(11): 3602-3606. |
| [13] |
ZHANG Xiao-lin1, LI Shou-zhe2*, JI Chun-jun1*, NIU Yu-long2, BAI Yang2, LIAO Hong-da2. Spectral Study on Combustion Supporting Effect of Plasma Jet for Methane Combustion in Air[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(10): 3251-3255. |
| [14] |
LI Zheng-kai1, CHEN Lei1*, WANG Mei-qi1, SONG Peng2, 3, YANG Kun1, ZENG Wen1. Diagnosis of Atmospheric Pressure Argon/Air Needle-Ring Dielectric Barrier Discharge Emission Spectrum[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(10): 3307-3310. |
| [15] |
CHEN Chuan-jie1, 2, FAN Yong-sheng3, FANG Zhong-qing1, 2, WANG Yuan-yuan1, 2, KONG Wei-bin1, 2, ZHOU Feng1, 2*, WANG Ru-gang1, 2. Research on the Electron Temperature in Nanosecond Pulsed Argon Discharges Based on the Continuum Emission[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(08): 2337-2342. |
|
|
|
|
