光谱学与光谱分析 |
|
|
|
|
|
Study on the Multivariate Quantitative Analysis Method for Steel Alloy Elements Using LIBS |
GU Yan-hong, LI Ying*, TIAN Ye, LU Yuan |
Optics and Optoelectronics Laboratory, Ocean University of China, Qingdao 266100, China |
|
|
Abstract Quantitative analysis of steel alloys was carried out using laser induced breakdown spectroscopy ( LIBS ) taking into account the complex matrix effects in steel alloy samples. The laser induced plasma was generated by a Q-switched Nd∶YAG laser operating at 1 064 nm with pulse width of 10 ns and repeated frequency of 10 Hz. The LIBS signal was coupled to the echelle spectrometer and recorded by a high sensitive ICCD detector. To get the best experimental conditions, some parameters, such as the detection delay, the CCD’s integral gate width and the detecting position from the sample surface, were optimized. The experimental results showed that the optimum detection delay time was 1.5μs, the optimal CCD’s integral gate width was 2 μs and the best detecting position was 1.5 mm below the alloy sample’s surface. The samples used in the experiments are ten standard steel alloy samples and two unknown steel alloy samples. The quantitative analysis was investigated with the optimum experimental parameters. Elements Cr and Ni in steel alloy samples were taken as the detection targets. The analysis was carried out with the methods based on conditional univariate quantitative analysis, multiple linear regression and partial least squares (PLS) respectively. It turned out that the correlation coefficients of calibration curves are not very high in the conditional univariate calibration method. The analysis results were obtained with the unsatisfied relative errors for the two predicted samples. So the conditional univariate quantitative analysis method can’t effectively serve the quantitative analysis purpose for multi-components and complex matrix steel alloy samples. And with multiple linear regression method, the analysis accuracy was improved effectively. The method based on partial least squares (PLS) turned out to be the best method among all the three quantitative analysis methods applied. Based on PLS, the correlation coefficient of calibration curve for Cr is 0.981 and that for Ni is 0.995. The concentrations of Cr and Ni in two target samples were determined using PLS calibration method, and the relative errors for the two unknown steel alloy samples are lower than 6.62% and 1.49% respectively. The obtained results showed that in the quantitative analysis of steel alloys, the matrix effect would be reduced effectively and the quantitative analysis accuracy would be improved by the PLS calibration method.
|
Received: 2013-07-28
Accepted: 2013-11-20
|
|
Corresponding Authors:
LI Ying
E-mail: liying@ouc.edu.cn
|
|
[1] Fabiano Barbieri Gonzaga, Celio Pasquini. Spectrochimica Acta Part B, 2012, 69: 20. [2] Rohit Kumar, Awadhesh K Rai, Devanathan Alamelu, et al. Environ. Monit. Assess., 2013, 185: 171. [3] Dario Santos Jr, Lidiane C Nunes, Lilian C Trevizan, et al. Spectrochimica Acta Part B, 2009, 64: 1073. [4] Yueh Fang-Yu, Zheng Hongbo, Jagdish P Singh, et al. Spectrochimica Acta Part B, 2009, 64: 1059. [5] Gabriela Vítková, Karel Novotny, Lubomír Proke, et al. Spectrochimica Acta Part B, 2012, 73: 1. [6] Fabienne Boué-Bigne. Spectrochimica Acta Part B, 2008, 63: 1122. [7] Gurell J, Bengtson A, Falkenstrm M, et al. Spectrochimica Acta Part B, 2012, 74-75: 46. [8] Fabiano Barbieri Gonzaga, Celio Pasquini. Spectrochimica Acta Part B, 2012, 69: 20. [9] Danielle Cleveland, Robert G Michel. Microchemical Journal, 2010, 95: 120. [10] Aguilera J A, Aragón C, Madurga V, et al. Spectrochimica Acta Part B, 2009, 64: 993. [11] Lasheras R J, Bello-Gálvez C, Anzano J M. Spectrochimica Acta Part B, 2013, 82: 65. [12] Jens Vrenegor, Reinhard Noll, Volker Sturm. Spectrochimica Acta Part B, 2005, 60: 1083. [13] WANG Zhe, FENG Jie, LI Zheng, et al(王 哲,冯 杰,李 政,等). J. Tsinghua Univ.·Sic. & Tech.(清华大学学报·自然科学版), 2010, 50(8): 1263. [14] Gabriele Cristoforetti, Stefano Legnaioli, Giulia Lorenzetti, et al. Spectrochimica Acta Part B, 2010, 40: 410. [15] Palanco S, Laserna J J. J. Anal. At. Spectrom., 2000, 15: 1321. [16] SUN Lan-xiang, YU Hai-bin, XIN Yong, et al(孙兰香, 于海滨,辛 勇,等). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2011, 31(2): 402. [17] Sorrentino F, Carelli G, Francesconi F, et al. Spectrochimica Acta Part B, 2009, 64: 1068. |
[1] |
LIU Jia1, 2, GUO Fei-fei2, YU Lei2, CUI Fei-peng2, ZHAO Ying2, HAN Bing2, SHEN Xue-jing1, 2, WANG Hai-zhou1, 2*. Quantitative Characterization of Components in Neodymium Iron Boron Permanent Magnets by Laser Induced Breakdown Spectroscopy (LIBS)[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2024, 44(01): 141-147. |
[2] |
YANG Wen-feng1, LIN De-hui1, CAO Yu2, QIAN Zi-ran1, LI Shao-long1, ZHU De-hua2, LI Guo1, ZHANG Sai1. Study on LIBS Online Monitoring of Aircraft Skin Laser Layered Paint Removal Based on PCA-SVM[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(12): 3891-3898. |
[3] |
SUN Cheng-yu1, JIAO Long1*, YAN Na-ying1, YAN Chun-hua1, QU Le2, ZHANG Sheng-rui3, MA Ling1. Identification of Salvia Miltiorrhiza From Different Origins by Laser
Induced Breakdown Spectroscopy Combined with Artificial Neural
Network[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(10): 3098-3104. |
[4] |
LIU Shu1, JIN Yue1, 2, SU Piao1, 2, MIN Hong1, AN Ya-rui2, WU Xiao-hong1*. Determination of Calcium, Magnesium, Aluminium and Silicon Content in Iron Ore Using Laser-Induced Breakdown Spectroscopy Assisted by Variable Importance-Back Propagation Artificial Neural Networks[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(10): 3132-3142. |
[5] |
LI Chang-ming1, CHEN An-min2*, GAO Xun3*, JIN Ming-xing2. Spatially Resolved Laser-Induced Plasma Spectroscopy Under Different Sample Temperatures[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2032-2036. |
[6] |
ZHAO Yang1, ZHANG Lei2, 3*, CHENG Nian-kai4, YIN Wang-bao2, 3*, HOU Jia-jia5, BAI Cheng-hua1. Research on Space-Time Evolutionary Mechanisms of Species Distribution in Laser Induced Binary Plasma[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2067-2073. |
[7] |
WANG Bin1, 2, ZHENG Shao-feng2, GAN Jiu-lin1, LIU Shu3, LI Wei-cai2, YANG Zhong-min1, SONG Wu-yuan4*. Plastic Reference Material (PRM) Combined With Partial Least Square (PLS) in Laser-Induced Breakdown Spectroscopy (LIBS) in the Field of Quantitative Elemental Analysis[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2124-2131. |
[8] |
HU Meng-ying1, 2, ZHANG Peng-peng1, 2, LIU Bin1, 2, DU Xue-miao1, 2, ZHANG Ling-huo1, 2, XU Jin-li1, 2*, BAI Jin-feng1, 2. Determination of Si, Al, Fe, K in Soil by High Pressure Pelletised Sample and Laser-Induced Breakdown Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2174-2180. |
[9] |
WU Shu-jia1, 2, YAO Ming-yin2, 3, ZENG Jian-hui2, HE Liang2, FU Gang-rong2, ZENG Yu-qi2, XUE Long2, 3, LIU Mu-hua2, 3, LI Jing2, 3*. Laser-Induced Breakdown Spectroscopy Detection of Cu Element in Pig Fodder by Combining Cavity-Confinement[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(06): 1770-1775. |
[10] |
YUAN Shu, WU Ding*, WU Hua-ce, LIU Jia-min, LÜ Yan, HAI Ran, LI Cong, FENG Chun-lei, DING Hong-bin. Study on the Temporal and Spatial Evolution of Optical Emission From the Laser Induced Multi-Component Plasma of Tungsten Carbide Copper Alloy in Vacuum[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(05): 1394-1400. |
[11] |
WANG Qiu, LI Bin, HAN Zhao-yang, ZHAN Chao-hui, LIAO Jun, LIU Yan-de*. Research on Anthracnose Grade of Camellia Oleifera Based on the Combined LIBS and Fourier Transform NIR Technology[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(05): 1450-1458. |
[12] |
CHAI Shu1, PENG Hai-meng1, WU Wen-dong1, 2*. Acoustic-Based Spectral Correction Method for Laser-Induced Breakdown Spectroscopy in High Temperature Environment[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(05): 1401-1407. |
[13] |
WANG Jin-mei, HE Shi, ZHANG Hang-xi, YANG Chen, YIN Yi-tong, ZHANG Li, ZHENG Pei-chao*. Study on the Detection Method of Nitrate Nitrogen in Water Based on
Ultraviolet Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(04): 1037-1042. |
[14] |
NING Qian-qian, YANG Jia-hao, LIU Xiao-lin, HE Yu-han, HUANGFU Zhi-chao, YU Wen-jing, WANG Zhao-hui*. Design and Study of Time-Resolved Femtosecond Laser-Induced
Breakdown Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(04): 1083-1087. |
[15] |
DING Kun-yan1, HE Chang-tao2, LIU Zhi-gang2*, XIAO Jing1, FENG Guo-ying1, ZHOU Kai-nan3, XIE Na3, HAN Jing-hua1. Research on Particulate Contamination Induced Laser Damage of Optical Material Based on Integrated Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(04): 1234-1241. |
|
|
|
|