|
|
|
|
|
|
Chloroformylation-Separation of Matrix and Determination of Trace Impurities in High Purity Chromium by ICP-MS |
WANG Jin-lei1, 2, QIAN Jun-min2, LI Bo1, LUO Lin1*, SUN Bao-lian1, XU Wei-jun2, CUI Ning2 |
1. Northwest Institute for Non-ferrous Metal Research, Xi’an 710016, China
2. State Key Laboratory for Mechanical Behavior of Materials, Xi’an Jiaotong University, Xi’an 710049, China |
|
|
Abstract A new method was developed for the determination of twelve different trace impurities in high purity chromium by ICP-MS after chloroformylation separation. The interferences on analytes and the pollution of sample introduction system were efficiently avoided by separation impurity elements from matrix chromium which makes use of chromyl chloride’ low boiling point. The influences of temperature and dosage of acid separation effects were studied. The content of 50V and 50Ti changing with the amount of residual chromium in sample solution was determined. The analytical results proved to be accurate and validated by comparing the proposed method with ICP-OES and AES with D. C electric as the excitation. Under optimized conditions, over 99.99% of the matrix chromium was removed by chloroformylation separation at 130 ℃ with the acid addition of 12 mL for 2 h, which eliminated the matrix effect and spectra interference in the following ICP-MS detection. It showed that the detection limit of the method was 0.000 01%~0.000 06%; the RSD was 1.7%~5.8%; and the recovery of standard addition was 90%~104%. The method is simple, applicative and suitable for the determination of impurities in high purity chromium of 99.99%.
|
Received: 2016-08-29
Accepted: 2016-12-21
|
|
Corresponding Authors:
LUO Lin
E-mail: abc2897luolin@163.com
|
|
[1] Pareige C, Kuksenko V, Pareige P. Journal of Nuclear Material., 2015, 456: 471.
[2] Bhattacharya A, Meslin E, Henry J, et al. Acta Materialia, 2016, 108: 241.
[3] Majid Mirzaee, Abolghasem Dolati. Applied Physics A, 2014, 130(1): 1.
[4] Bhattacharya A, Meslin E, Henry J, et al. Acta Materialia, 2014, 78: 394.
[5] Kuksenko V, Pareige C, Pareige P. Journal of Nuclear Materials, 2013, 432: 160.
[6] GB/T 28908-2012, High-Purity Chromium Metal. National Standards of the People’s Republic of China(高纯金属铬. 中华人民共和国国家标准. GB/T 28908-2012).
[7] Bettaibi A, M’nassri R, Selmi A, et al. Applied Physics A., 2016, 122(3): 1.
[8] Serife Tokahoglu, Senol Kartal, Elci L. Microchimica Acta, 1997, 127(3): 281.
[9] Hassler J, Barth P, Richter S, et al. J. Anal. At. Spectrum, 2011, 26(12): 2404.
[10] Shin-Ichi H, Yamaguchi H, Yamada K, et al. Journal of the Japan Institute of Metals, 2004, 45(3): 925.
[11] Becker J S, Pickhardt C, Dietze H J. Journal of Analytical Atomic Spectrometry, 2001, 16(6): 603.
[12] Ana B P L, Silmara R B RenatoL. Food Analytical Methods, 2014, 7(5): 1009.
[13] ZHOU Shi-ping, ZHU Guang-hui, YIN Jia-yuan, et al(周世萍, 朱光辉, 尹家元, 等). Chinese J. Anal. Chem.(分析化学), 2002, 30(1): 66.
[14] WEI Jian-jun, LANG Chun-yan, LIN Long-fei, et al(魏建军, 郎春燕, 林龙飞, 等). Chinese J. Anal. Chem.(分析化学), 2013, 41(6): 927.
[15] WEI Jian-jun, LANG Chun-yan, LIN Long-fei, et al(魏建军, 郎春燕, 林龙飞, 等). Chinese J. Anal. Chem.(分析化学), 2013, 41(9): 1454.
[16] XU Wei, LI Yu-zhen, DUAN Tai-cheng, et al(徐 伟, 李育珍, 段太成, 等). Chinese J. Anal. Chem.(分析化学), 2015, 43(9): 1349.
[17] Thangavel S, Dash K, Dhavile S M, et al. Talanta, 2015, 131(1): 505. |
[1] |
SUN Chuan-qiang, GONG Zi-shan, WANG Xiao-jun, YANG Ru, JIANG Xue-hui, WANG Yan*. Characterization and Determination of Gold Nanoparticles by SP-ICP-MS[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2018, 38(07): 2267-2273. |
[2] |
FANG Fang1, JI Yu-shan1, BAI Na1, LI Xiang1, LIU Ying1, 2*. Study on Adsorption and Desorption Characteristics of Cd2+ and Zn2+ on the Surface Sediments of Taihu Lake by Using ICP-MS[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2018, 38(06): 1889-1895. |
[3] |
HUI Cen-yi, FENG Jin-chao, SHI Sha*. Study on the Determination of Mineral Elements in Three Caragana Fabr. Species in Inner Mongolia by Inductively Coupled Plasma Mass Spectrometry[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2018, 38(04): 1240-1244. |
[4] |
FANG Fang1, JI Yu-shan1, LI Xiang1, BAI Na1, LIU Ying1,2*. Assessment of Pollution and Heavy Metals in Filtered Water and Surface Sediments of Taihu Lake by Using ICP-MS[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2018, 38(04): 1245-1250. |
[5] |
WEI Guo-feng1, QIN Ying2*, WANG Le-qun3. Study on Copper Ores Source of Bronze Vessels in Zongyang County, Anhui Province, Dated from the Western Zhou Dynasty to Warring States Period[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2017, 37(11): 3610-3615. |
[6] |
TIAN Meng-jing1, JIA Jia1, QIAO Yu1, WU Ting-yan1, LI He-xiang1, LIU Ying1, 2*. Study on Adsorption and Desorption Characteristics of Pb(Ⅱ) and Cr(Ⅵ) onto the Surface Sediments of Hequ Section of the Yellow River with ICP-MS[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2017, 37(06): 1902-1907. |
[7] |
TIAN Meng-jing1, MA Xiao-ling1, JIA Jia1, QIAO Yu1, WU Ting-yan1, LI He-xiang1, LIU Ying1,2*. Study of Residents’ Exposure to Arsenic Near the Yellow River Gan-Ning-Meng Reaches Using Inductively Coupled Plasma Mass Spectrometry[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2017, 37(05): 1628-1633. |
[8] |
LI Jian-ting1, 2, ZHANG Yi-ming2, DU Mei2, HAO Qian2, LI Jian-qiang1*. Study on the Interferences and Direct Determination of Sc in Metallurgical Tails with Inductively Coupled Plasma Mass Spectrometry[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2017, 37(04): 1259-1263. |
[9] |
ZUO Hang1,3, CHEN Yi-zhen1, CHEN Jian-hua1, GUO Yang1, WANG Ru-ming1, FANG Fang1, ZHAO Jia-ying1, LIU Ying1,2*. Study on Adsorption and Desorption Characteristics of Cd2+ and Cu2+ on the Surface Sediments of Sanhuhekou of Yellow River by Using ICP-MS[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2017, 37(03): 902-909. |
[10] |
NIE Xi-du1, FU Liang2* . Simultaneous Determination of Impurity Elements in N-Methyl-2- Pyrrolidone (NMP) with Direct Injection Inductively Coupled Plasma Optical Emission Spectrometry[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2017, 37(03): 910-913. |
[11] |
LIU Hong-wei1, XIE Hua-lin2*, NIE Xi-du1 . Determination of Impurity Elements in Rosin with Inductively Coupled Plasma Mass Spectrometry [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2017, 37(02): 603-606. |
[12] |
MI Hai-peng1, ZHU Hong-ming1, LI Gen-rong1, YU Xiang1, MA Bing-bing2, ZHOU Xi-lin2, WANG Ya-sen2, SU Zhong-hua2, DENG Xiong2. Determination of Pb, Cr, Cd, and As in Aluminum-Plastic Packaging Materials via Inductively Coupled Plasma-Mass Spectrometry with Microwave Digestion[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2017, 37(02): 646-650. |
[13] |
XU Juan1*, YANG Shou-ye1, HU Zhao-chu2, LUO Tao2, HUANG Xiang-tong1 . A New Sample Fusion Technique for Quantitative Analysis of Major and Minor Elements in Sulfides with X-Ray Fluorescence Spectrometry and Laser Ablation Inductively Coupled Plasma Mass Spectrometry[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2016, 36(11): 3683-3688. |
[14] |
NIE Xi-du1, FU Liang2* . Determination of Trace Impurity Elements in Food Grade Chitosan with Inductively Coupled Plasma Mass Spectrometry[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2016, 36(08): 2621-2624. |
[15] |
JIANG Bo1, TANG Li-Juan2, HUANG Jian-hua3*. Study on the Inorganic Components Elements in Rare and Endangered Plant Alsophila Spinulosa[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2016, 36(05): 1468-1472. |
|
|
|
|