|
|
|
|
|
|
| A Review of Calibration Transfer Based on Spectral Technology |
| LI Xue-ying1, 2, 3, 4, FAN Ping-ping1, 3, 4*, HOU Guang-li1, 3, 4, QIU Hui-min1, 3, 4, LÜ Hong-min1, 3, 4 |
1. Institute of Oceanographic Instrumentation, Qilu University of Technology (Shandong Academy of Sciences), Qingdao 266061, China
2. School of Geosciences, China University of Petroleum (Huadong), Qingdao 266580, China
3. Shandong Provincial Key Laboratory of Ocean Environmental Monitoring Technology, Qingdao 266061, China
4. National Engineering and Technological Research Center of Marine Monitoring Equipment, Qingdao 266061, China |
|
|
|
|
Abstract Generally, the multivariate calibration model based on spectroscopy is only for the same instrument, the same test conditions and the same batch or similar samples. However, with the increasing demand for spectral application, the problem that different samples cannot share the spectral model has become the fundamental technical bottleneck limiting spectral technology application. In the visible near-infrared spectrum analysis, after the change of the instrument, the test environment and the sample, the established spectral model is no longer suitable. So the model transfer is needed to solve this kind of problem. The model transfer is the key technology bottleneck to limit the application of spectral technology. Therefore, this paper summarizes the current research situation and discusses future development direction. First of all, the model transfer problem is divided into two categories: the first is the model mismatch of the same sample under different instruments or different test environments, called the first type of model transfer; the second is the model mismatch between different samples, called the second type of model transfer. These two kinds of problems are different in nature. To solve the first type of model transfer can ensure the accuracy and stability of homologous samples. And to solve the second type can realize the automatic transfer and matching application of spectral model between different products. Then, the commonly used model transfer algorithms are sorted and classified, including model updating, spectrum based correction algorithm, result based correction algorithm, and the application of each category of model transfer algorithm is listed. Model updating is the most direct method for recalculating model coefficients, which can meet the new changes by expanding and adjusting the model. Spectrum based correction algorithm is based on the calculation of the transfer matrix to achieve spectral correction. Result based correction algorithm is based on the calculation of pre-test results and actual results coefficients, so as to achieve the correction of prediction results. Finally, it is pointed out that the second type of model transfer should be studied in the future, especially the automatic model transfer by machine, so as to realize the real spectral velocity measurement.
|
|
Received: 2020-04-09
Accepted: 2020-10-06
|
|
|
|
Corresponding Authors:
FAN Ping-ping
E-mail: fanpp_sdioi@126.com
|
|
[1] Guo Y, Ni Y, Kokot S. Spectrochimica Acta Part A: Molecular and Biomolecular Spectroscopy, 2015, 153: 79.
[2] Li X Y, Fan P P, Liu Y, et al. Journal of Applied Spectroscopy，2019, 86(4): 765.
[3] CHU Xiao-li, XU Yu-peng, LU Wan-zhen（褚小立, 许育鹏, 陆婉珍）. Chinese Journal of Analytical Chemistry（分析化学）, 2008, 36(5): 702.
[4] ZHANG Jin, CAI Wen-sheng, SHAO Xue-guang(张 进，蔡文生，邵学广). Progress in Chemistry（化学进展）, 2017，29(8): 902.
[5] Xiao H, Sun K, Sun Y, et al. Sensors, 2017, 17(11): e2818.
[6] Andries E. Journal of Chemometrics, 2017, 31(4): si.
[7] Yahaya O K M, MatJafri M Z, Aziz A A, et al. Journal of Instrumentation，2015, 10(5): T05002.
[8] Yang J X, Lou X P, Yang H Q, et al. Analytical Letters, 2019, 52(14): 2188.
[9] Fernandez L, Guney S, Gutierrez-Galvez A, et al. Sensors and Actuators B: Chemical, 2016, 231: 276.
[10] Wang A D, Yang P, Chen J, et al. Infrared Physics & Technology, 2019, 103：103046.
[11] Qiao L, Lu B, Dong J, et al. Spectroscopy Letters, 2020, 53(1): 44.
[12] Pereira L S A, Carneiro M F, Botelho B G, et al. Talanta, 2016, 147: 351.
[13] Li X Y, Liu Y, Lv M R, et al. Journal of Spectroscopy, 2018, 2018: 8513215.
[14] Wu Y, Jin Y, Li Y, et al. Vib. Spectrosc., 2012, 58: 109.
[15] Xie L, Yang Z, Tao D, et al. Spectroscopy Letter, 2019, 52(10): 642(doi: 10.1080/00387010.2019.1681463).
[16] CHU Xiao-li, YUAN Hong-fu, LU Wan-zhen, et al（褚小立, 袁洪福, 陆婉珍，等）. Spectroscopy and Spectral Analysis（光谱学与光谱分析）, 2001，20(6): 146.
[17] ZHENG Kai-yi, FAN Wei, WU Ting, et al（郑开逸, 范 伟, 吴 婷, 等）. Computers and Applied Chemistry（计算机与应用化学）, 2013, 30(3): 246.
[18] Liu Y, Xu H, Xia Z Z, et al. Analyst, 2018, 143(5): 1274.
[19] Noord O E D. Chemometrics and Intelligent Laboratory Systems, 1994, 25(2): 85. |
| [1] |
CHENG Jia-wei1, 2，LIU Xin-xing1, 2*，ZHANG Juan1, 2. Application of Infrared Spectroscopy in Exploration of Mineral Deposits: A Review[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2024, 44(01): 15-21. |
| [2] |
GAO Feng1, 2, XING Ya-ge3, 4, LUO Hua-ping1, 2, ZHANG Yuan-hua3, 4, GUO Ling3, 4*. Nondestructive Identification of Apricot Varieties Based on Visible/Near Infrared Spectroscopy and Chemometrics Methods[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2024, 44(01): 44-51. |
| [3] |
CHU Bing-quan1, 2, LI Cheng-feng1, DING Li3, GUO Zheng-yan1, WANG Shi-yu1, SUN Wei-jie1, JIN Wei-yi1, HE Yong2*. Nondestructive and Rapid Determination of Carbohydrate and Protein in T. obliquus Based on Hyperspectral Imaging Technology[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(12): 3732-3741. |
| [4] |
ZHENG Ni-na1, 2*, XIE Pin-hua1, QIN Min1, DUAN Jun1. Research on the Influence of Lamp Structure of the Combined LED Broadband Light Source on Differential Optical Absorption Spectrum
Retrieval and Its Removing Method[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(11): 3339-3346. |
| [5] |
HE Yan-ping, WANG Xin, LI Hao-yang, LI Dong, CHEN Jin-quan, XU Jian-hua*. Room Temperature Synthesis of Polychromatic Tunable Luminescent Carbon Dots and Its Application in Sensitive Detection of Hemoglobin[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(11): 3365-3371. |
| [6] |
ZHANG Shu-fang1, LEI Lei2, LEI Shun-xin2, TAN Xue-cai1, LIU Shao-gang1, YAN Jun1*. Traceability of Geographical Origin of Jasmine Based on Near
Infrared Diffuse Reflectance Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(11): 3389-3395. |
| [7] |
KANG Ming-yue1, 3, WANG Cheng1, SUN Hong-yan3, LI Zuo-lin2, LUO Bin1*. Research on Internal Quality Detection Method of Cherry Tomatoes Based on Improved WOA-LSSVM[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(11): 3541-3550. |
| [8] |
GUO Ge1, 3, 4, ZHANG Meng-ling3, 4, GONG Zhi-jie3, 4, ZHANG Shi-zhuang3, 4, WANG Xiao-yu2, 5, 6*, ZHOU Zhong-hua1*, YANG Yu2, 5, 6, XIE Guang-hui3, 4. Construction of Biomass Ash Content Model Based on Near-Infrared
Spectroscopy and Complex Sample Set Partitioning[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(10): 3143-3149. |
| [9] |
ZHANG Yue1, 3, ZHOU Jun-hui1, WANG Si-man1, WANG You-you1, ZHANG Yun-hao2, ZHAO Shuai2, LIU Shu-yang2*, YANG Jian1*. Identification of Xinhui Citri Reticulatae Pericarpium of Different Aging Years Based on Visible-Near Infrared Hyperspectral Imaging[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(10): 3286-3292. |
| [10] |
ZHANG Jun-he, YU Hai-ye, DANG Jing-min*. Research on Inversion Model of Wheat Polysaccharide Under High Temperature and Ultraviolet Stress Based on Dual-Spectral Technique[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(09): 2705-2709. |
| [11] |
YU Yang1, ZHANG Zhao-hui1, 2*, ZHAO Xiao-yan1, ZHANG Tian-yao1, LI Ying1, LI Xing-yue1, WU Xian-hao1. Effects of Concave Surface Morphology on the Terahertz Transmission Spectra[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(09): 2843-2848. |
| [12] |
LI Xin-xing1, 2, ZHANG Ying-gang1, MA Dian-kun1, TIAN Jian-jun3, ZHANG Bao-jun3, CHEN Jing4*. Review on the Application of Spectroscopy Technology in Food Detection[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(08): 2333-2338. |
| [13] |
ZHANG Zi-hao1, GUO Fei3, 4, WU Kun-ze1, YANG Xin-yu2, XU Zhen1*. Performance Evaluation of the Deep Forest 2021 (DF21) Model in
Retrieving Soil Cadmium Concentration Using Hyperspectral Data[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(08): 2638-2643. |
| [14] |
LI Bin, SU Cheng-tao, YIN Hai, LIU Yan-de*. Hyperspectral Imaging Technology Combined With Machine Learning for Detection of Moldy Rice[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(08): 2391-2396. |
| [15] |
PU Gui-juan1, 2, CHENG Si-yang3*, LI Song-kui4, LÜ Jin-guang2, CHEN Hua5, MA Jian-zhong3. Spectral Inversion and Variation Characteristics of Tropospheric NO2
Column Density in Lhasa, Tibet[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(06): 1725-1730. |
|
|
|
|
