|
|
|
|
|
|
| In Situ Detection of Structural Evolution of Isotropic Polypropylene Crystals During Uniaxial Stretching by Two-Dimensional X-Ray Diffraction Spectroscopy |
| XU Ming-kun, LIN Jia-xiang, ZHANG Xiao-lin, LI Zhen-yin, WANG Ya-ming, LIU Chun-tai, SHEN Chang-yu, SHAO Chun-guang* |
Key Laboratory of Materials Processing and Mold, Ministry of Education, National Engineering Research Center for Advanced Polymer Processing Technology, Zhengzhou University, Zhengzhou 450001, China
|
|
|
|
|
Abstract In using polymer products, people are most concerned about their failure conditions, and the important manifestation of failure is the yield of the material. So far, the dislocation theory has been widely used to explain the yielding phenomenon of polymer materials. This theory usually focuses on the crystal orientation and destruction while ignoring the crystal deformation and the stress acting on the crystal. The orientation and destruction of the crystal are only the results of the yielding, and the ability of the crystal to withstand stress is the direct cause of yielding. Therefore, this paper will start from the stress and inhomogeneous deformation of crystals to study the yielding behavior of polymer products, hoping to provide new ideas for understanding the failure behavior of polymer materials. Here, the widely used isotactic polypropylene (iPP) material is selected as the research object, and iPP samples with different lamellar thicknesses are prepared by isothermal crystallization of iPP melt at different temperatures. Two-dimensional wide-angle X-ray diffraction spectroscopy was used to monitor in situ the crystal destruction and crystal orientation processes of the iPP samples during stretching. The “covering method” was used to process the two-dimensional X-ray diffraction patterns for the first time, the change of the 2θ angle of the (110) crystal planes during the stretching process was observed in situ, and the deformation of the crystal in two directions (parallel to the stretching direction and perpendicular to the stretching direction) was distinguished. The results show that for iPP crystals with different lamellar thicknesses, the inhomogeneous deformation of the crystals during the uniaxial stretching process is a common phenomenon; the destruction and orientation of the crystals always occur at the same time, starting from the yield point, which is independent of the lamella thickness; the critical stress corresponding to the crystal destruction is related to the thickness of the crystal. The thicker the lamellae and the more stable the crystal, the greater the critical stress required. The above results show that in situ X-ray diffraction spectroscopy can observe the crystal structure changes during the stretching process in real time, thereby directly correlating the crystal structure evolution with the macroscopic mechanical properties.
|
|
Received: 2022-03-01
Accepted: 2022-06-30
|
|
|
|
Corresponding Authors:
SHAO Chun-guang
E-mail: shaochg@zzu.edu.cn
|
|
[1] Cao Tian, Chen Xiaowei, Lin Yuanfei, et al. Macromolecular Materials and Engineering, 2018, 303(2): 1700493.
[2] Li Yiguo, Duan Tianchen, Yao Guibin, et al. Composites Science and Technology, 2019, 183: 107798.
[3] Shmueli Yuval, Lin Yu-Chung, Lee Sungsik, et al. ACS Applied Materials & Interfaces, 2019, 11: 37112.
[4] ZHANG Zhi-dan, ZHAO Min-shuang, ZHANG Li-na, et al(张志丹，赵旻爽，张丽娜，等). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2021, 41(2): 529.
[5] Ma Zhe, Shao Chunguang, Wang Xiao, et al. Polymer, 2009, 50(12): 2706.
[6] Shao Chunguang, An Haining, Wang Xiao, et al. Macromolecules, 2007, 40(26): 9475.
[7] Liu Guoming, Zhang Xiuqin, Liu Yufeng, et al. Polymer, 2013, 54(4): 1440.
[8] FU Si-rui, YANG Jing-hui, FU Qiang(傅思睿，杨静晖，傅 强). Acta Polymerica Sinica(高分子学报), 2012, (3): 344.
[9] Bowden P B, Young R J. Journal of Materials Science, 1974, 9(12): 2034.
[10] Wang Yu, Zhu Ping, Lai Yue, et al. Polymer, 2021, 225: 123802.
[11] Men Y, Strobl G. Macromolecules, 2003, 36(6): 1889.
[12] Shao Chunguang, Ma Zhe, Zhuo Ranran, et al. Journal of Materials Science, 2012, 47(7): 3334.
[13] Miao Zhongshuo, Men Yongfeng. Polymer, 2020, 186: 122038.
[14] Auriemma Finizia, Scoti Miriam, Girolamo Rocco Di, et al. Polymer, 2020, 199: 122540.
[15] Liu Yanping, Cui Kunpeng, Tian Nan, et al. Macromolecules, 2012, 45(6): 2764.
[16] Martins C I, Cakmak M. Macromolecules, 2005, 38(10): 4260.
[17] Men Yongfeng, Rieger Jens, Strobl G. Physical Review Letters, 2003, 91(9): 095502.
|
| [1] |
HUANG Bao-kun1*, ZHAO Qian-nan2, LIU Ye-fan2, ZHU Lin1, ZHANG Hong2, ZHANG Yun-hong3*, LIU Yan4*. In Situ Detection of Fuel Engine Exhaust Components by Raman
Integrating Sphere[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(10): 3310-3313. |
| [2] |
ZHANG Yun-gang1, LIU Huang-tao1, GAO Qiang2, ZHU Zhi-feng2, LI Bo2, WANG Yong-da1. In-Situ Detection of SF6 Decomposition Products Based on Femtosecond Laser-Guided High-Voltage Discharge[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(02): 414-418. |
| [3] |
LIU Yan-yan1, TAO Ning-ping1, 2, 3, WANG Xi-chang1, 2, 3, LU Ying1, 2, 3*，XU Chang-hua1, 2, 3*. Integrated Detection of Foodborne Pathogens by In-Situ Infrared Spectroscopy Based on ZnSe Film Transmission Method[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(02): 419-424. |
| [4] |
ZHOU Peng, LI Min-zan*, YANG Wei, JI Rong-hua, MENG Chao. Development of Vehicle-Mounted in-situ Soil Parameters Detector Based on NIR Diffuse Reflection[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2020, 40(09): 2856-2861. |
| [5] |
ZHU De-hua1, 2, WANG Man-cang1, 2, XU Ling-jie1, 2, CHEN Xiao-jing3, SUN Bing-tao1, 2, ZHANG Jian1, 2, LIU Wen-wen1, 2, CAO Yu1, 2, YUAN Lei-ming3, CAI Yan1*. Detection of Pb Element Composition in Irregular Copper Alloy Samples Based on Multi-Line Internal Standard Method[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2019, 39(10): 3159-3163. |
| [6] |
WU Xin1，2, LI Guang-lin1*, WEN Zhi-yu3. Study and Determination the Concentration of CNO-Ion of the QPQ with the Sequential Injection Spectrophotometric Method[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2018, 38(06): 1824-1828. |
| [7] |
DU Ling-ling，CHEN Wei-gen，GU Zhao-liang，ZOU Jing-xin，WAN Fu. Application of Raman Spectroscopy to Analyze Acetic Acid Content Dissolved in Transformer Oil[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2017, 37(09): 2774-2779. |
| [8] |
REN Zhong-yuan, WU Yu-qing* . In Situ Infrared Spectroscopic Determination of Enzyme Activity [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2015, 35(08): 2087-2093. |
| [9] |
HAN Ping, WANG Ji-hua*, LU An-xiang, MA Zhi-hong, PAN Li-gang . Analysis of Heavy Metal in Soil with Portable X-Ray Fluorescence Spectrometry[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2012, 32(03): 826-829. |
|
|
|
|
