Application and Analysis of Multi-Component Simultaneous Measurement of Forest Combustibles Pyrolysis Gas Based on TDLAS
GUO Song-jie1, WANG Lu-peng2, CHEN Jin-zheng1, MA Yun2, LIANG An2, LU Zhi-min1, YAO Shun-chun1*
1. School of Electric Power Engineering, South China University of Technology, Guangzhou 510640, China
2. Yunfu Fire and Rescue Detachment, Yunfu 527399, China
Abstract：Pyrolysis of forest combustibles is an important research topic in forest fires and is of great significance for early warning and control of forest fires. The pyrolysis of forest combustibles mainly produces carbonaceous gases such as CO, CO2, and CH4. The continuous release of these gases will likely trigger forest fires and aggravate the greenhouse effect. The rapid and accurate detection of the concentrations of these three components is beneficial for early warning of fires and atmospheric environmental protection. In this paper, the concentrations of three CO, CO2, and CH4 components in the pyrolysis gases of six mountain forest tree species samples were accurately measured by frequency division multiplexing combined with tunable diode laser absorption spectroscopy (TDLAS) technique. The applicability of the frequency division multiplexing-TDLAS technique for simultaneous multi-component measurements of pyrolysis gases of forest combustibles is demonstrated. Firstly, the basic principle of the frequency division multiplexing-TDLAS technique is introduced, and the absorption spectra of the three components are determined without interfering with each other and with suitable spectral intensity. Secondly, the characteristics of the second harmonic (2f) signal and the second harmonic/DC (2f/DC) signal are investigated to invert the different concentrations accurately. The difference in the accuracy of inversion of different concentrations using the 2f signal and 2f/DC signal is compared using Simulink simulation, and the results show that the 2f/DC signal has a larger linear interval and is suitable for the measurement of different concentration components in the pyrolysis gas of forest combustibles. Finally, an experimental setup for simultaneous CO, CO2, and CH4 measurements was built using two distributed feedback (DFB) lasers with center wavelengths of 1 580.0 and 1 653.7 nm, respectively. The 2f/DC signals of the three components were measured using a Herriott absorber cell, and the absolute concentrations of the three components in the pyrolysis gas were obtained by establishing calibration models with standard gases. The results showed that the peak 2f/DC signals of the three components satisfied a good linear relationship with the concentrations withlinearity greater than 0.995, and the concentrations of CO in the pyrolysis gases of the six tree samples were significantly higher than those of CO2, and CH4 under the effect of the coke gasification reaction and Boundouard reaction. by analyzing the spectra of Chinese sweetgum leaf samples, it was shown that within the 2 s measurement time, the spectroscopic system for CO, CO2, and CH4 with a minimum detection limit lower than 0.008% and sensitivity better than 0.005%, which meets the demand of forest fire early warning. This study provides a methodological reference for the simultaneous multi-component measurement of pyrolysis gases of forest combustibles and forest fire early warning.
郭松杰，王璐鹏，陈金铮，马 云，梁 安，卢志民，姚顺春. TDLAS在森林可燃物热解气体多组分同步测量中的应用分析[J]. 光谱学与光谱分析, 2024, 44(03): 625-631.
GUO Song-jie, WANG Lu-peng, CHEN Jin-zheng, MA Yun, LIANG An, LU Zhi-min, YAO Shun-chun. Application and Analysis of Multi-Component Simultaneous Measurement of Forest Combustibles Pyrolysis Gas Based on TDLAS. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2024, 44(03): 625-631.
[1] Grassi G, House J, Dentener F, et al. Nature Climate Change, 2017, 7(3): 220.
[2] Barmpoutis P, Papaioannou P, Dimitropoulos K, et al. Sensors, 2020, 20(22): 6442.
[3] CHEN Bo-xuan, GUO Yan, FAN Jia-le, et al（陈伯轩，郭 妍，范佳乐，等）. Chinese Journal of Applied Ecology（应用生态学报）, 2022, 33(1): 76.
[4] ZHANG Jia-wei, ZHANG Hong-li, LI Ming-bao（张佳薇，张红丽，李明宝）. Forest Engineering（森林工程）, 2013, 29(2): 139.
[5] LI Chun-yang, ZHANG Yun-lin, GUO Yan, et al（李春阳，张运林，郭 妍，等）. Journal of Central South University of Forestry & Technology（中南林业科技大学学报）, 2020, 40(6): 81.
[6] Liu X N, Qiao S D, Ma Y F. Optics Express, 2022, 30(2): 1304.
[7] Ma Y F, Lewicki R, Razeghi M, et al. Optics Express, 2013, 21(1): 1008.
[8] Hu J, Niu H, Carrasco J, et al. Aerospace Science and Technology, 2022, 123: 107494.
[9] Bogue R. Sensor Review，2013, 33(2): 99.
[10] NIE Wei, KAN Rui-feng, YANG Chen-guang, et al（聂 伟，阚瑞峰，杨晨光，等）. Chinese Journal of Lasers（中国激光）, 2018, 45(9): 9.
[11] Liu X N, Ma Y F. Sensors, 2022, 22(16): 6095.
[12] So S, Park J, Yoo M, et al. Optics Express, 2022, 30: 32031.
[13] CHEN Xiang, KAN Rui-feng, YANG Chen-guang, et al（陈 祥，阚瑞峰，杨晨光，等）. Acta Optica Sinica（光学学报）, 2018, 38(5): 124.
[14] SUN Peng-shuai, ZHANG Zhi-rong, XIA Hua, et al（孙鹏帅，张志荣，夏 滑，等）. Acta Optica Sinica（光学学报）, 2015, 35(2): 334.
[15] Zhu X R, Yao S C, Ren W, et al. Applied Sciences, 2019, 9(3): 442.
[16] Liu J X, Zhou Y T, Guo S J, et al. Optics Express, 2019, 27: 1249.
[17] ZHU Yan-jun, FAN Xiao-hua, GAO Chao, et al（朱雁军，樊孝华，高 潮，等）. Laser Journal（激光杂志）, 2017, 38(5): 40.
[18] REN Shao-ran, LI Hai-kui, LI Lei-bing, et al（任韶然，李海奎，李磊兵，等）. Natural Gas Industry（天然气工业）, 2013, 33(10): 110.
