|
|
|
|
|
|
| Effect of Acidification Pretreatment on the Composition and Structure of Soluble Organic Matter in Coking Coal |
| WANG Fang-fang1, ZHANG Xiao-dong1, 2*, PING Xiao-duo1, ZHANG Shuo1, LIU Xiao1, 2 |
1. School of Energy Science and Engineering, Henan Polytechnic University, Jiaozuo 454000, China
2. Department of Geology and Surveying and Mapping Engineering, Shanxi University of Energy, Jinzhong 030600, China
|
|
|
|
|
Abstract In order to explore the influence of acidification pretreatment on the extractable composition and macromolecular structure of coal, Gujiao coking coal in Shanxi Province was acidified and demineralized by HCl and HF, and different concentrations of tetrahydrofuran (THF) were selected for solvent extraction experiments of raw coal (RC) and acidified coal (DC). The extraction of raw coal and acidified coal were compared and analyzed using modern technical means such as GC-MS and FTIR. The results show that with the increase of solvent concentration, the extraction rate of raw coal and acidified coal tends to increase. After acidification, the minerals in coal decrease significantly, the solvent permeability increases, and the extraction rate increases. However, acidification pretreatment has no noticeable effect on the extraction rate of high-concentration THF because high-concentration THF solvent can extract dissoluble components from coking coal to a large extent, and acidification pretreatment has a relatively weak promotion effect on dissoluble components. Therefore, with the increase of solvent concentration, raw coal and acidified coal have no apparent effect. After acidification pretreatment, the value of the hydrogen-rich degree parameter (I1) of coal samples decreased significantly, which was 0.61 less than raw coal. With the increase of THF concentration, the I1 value of raw coal decreased first and then increased, while the I1 value of acidified coal increased first and then decreased, showing opposite trends. The aromatization degree parameter (I2) and oxygen enrichment degree parameter (I3) increase obviously, in which I2 value is twice that of raw coal, I3 value is 11.82, almost three times that of raw coal, and after THF extracts raw coal with different concentrations, the oxygen index I3 value increases first and then decreases, while acidified coal decreases. The fat structure parameter (I4) is obviously reduced, which is only 8% of the raw coal, and the I4 value of its raffinate is far lower than that of the raw coal raffinate. The relative content of heteroatom compounds in acidified coal extract is significantly reduced by 83.14%~89.64%, and the relative content of aliphatic hydrocarbons is significantly increased, which is 5~26 times of that in raw coal extract, mainly including straight-chain hydrocarbons such as eicosane, docosane and triacontane, among which C19—C23 accounts for 79.17% of the total components of the extract. Aromatic substances are not found in extracts and only in 100%THF extracts in raw coal, with little change in relative content. It is considered that acidification pretreatment greatly influences the fat structure and oxygen-containing compounds in coal but has a relatively small influence on the aromatic structure.
|
|
Received: 2021-01-25
Accepted: 2021-02-28
|
|
|
|
Corresponding Authors:
ZHANG Xiao-dong
E-mail: z_wenfeng@163.com
|
|
[1] He Xueqiu, Liu Xianfeng, Nie Baisheng, et al. Fuel, 2017, 206: 555.
[2] HAO Zong-chao, ZHANG Xiao-dong, YANG Yan-qing, et al(郝宗超, 张小东, 杨燕青, 等). Journal of China Coal Society(煤炭学报), 2018, 43(10): 2903.
[3] Jorjani E, Chapi H G, Khorami M T. Fuel Process. Technol., 2011, 92(10): 1898.
[4] ZHANG Xiao-dong, YU Kun-kun, ZHANG Shuo, et al(张小东, 余坤坤, 张 硕, 等). Coal Conversion(煤炭转化), 2017, 40(3): 1.
[5] Song Yinmin, Feng Wei, Li Na, et al. Fuel, 2016, 183: 659.
[6] JIANG Chang-bao, LIN Jun, WANG Liang, et al(蒋长宝, 林 骏, 王 亮, 等). Coal Science and Technology(煤炭科学技术)，2018, 46(9): 163.
[7] LI Sheng, LUO Ming-kun, FAN Chao-jun, et al(李 胜, 罗明坤, 范超军, 等). Journal of China Coal Society(煤炭学报), 2017, 42(7): 1748.
[8] ZHAO Yun-gang, LI Mei-fei, ZENG Fan-gui, et al(赵云刚, 李美芬, 曾凡桂, 等). Journal of China Coal Society(煤炭学报), 2018, 43(2): 546.
[9] LIU Li-bao, YAO Hui-fang, JI Xin-qiang(刘利宝, 要惠芳, 姬新强). Coal Conversion(煤炭转化), 2016, 39(4): 10.
[10] GE Tao, ZHANG Ming-xu, CAI Chuan-chuan(葛 涛, 张明旭, 蔡川川). Journal of China Coal Society(煤炭学报), 2017, 42(S2): 500.
[11] JI Xin-qiang, YAO Hui-fang, LI Wei(姬新强, 要惠芳, 李 伟). Journal of China Coal Society(煤炭学报), 2016, 41(8): 2050.
[12] LI Na, LIU Quan-sheng, ZHEN Ming, et al(李 娜, 刘全生, 甄 明, 等). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2016, 36(9): 2760.
[13] ZHANG Wei, SONG Qiang, ZHANG Fan(张 薇, 宋 强, 张 帆). Coal Conversion(煤炭转化), 2019, 42(3): 1.
[14] ZHANG Zi-lei, WANG Qi-bao(张子磊, 王启宝). Coal Conversion(煤炭转化), 2020, 43(1): 1.
[15] Kou J W, Bai Z Q, Bai J, et al. Fuel Process. Technol., 2016, 152: 46.
|
| [1] |
MA Fang1, HUANG An-min2, ZHANG Qiu-hui1*. Discrimination of Four Black Heartwoods Using FTIR Spectroscopy and
Clustering Analysis[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2022, 42(06): 1915-1921. |
| [2] |
ZHANG Dian-kai1, LI Yan-hong1*, ZI Chang-yu1, ZHANG Yuan-qin1, YANG Rong1, TIAN Guo-cai2, ZHAO Wen-bo1. Molecular Structure and Molecular Simulation of Eshan Lignite[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2022, 42(04): 1293-1298. |
| [3] |
HU Chao-shuai1, XU Yun-liang1, CHU Hong-yu1, CHENG Jun-xia1, GAO Li-juan1, ZHU Ya-ming1, 2*, ZHAO Xue-fei1, 2*. FTIR Analysis of the Correlation Between the Pyrolysis Characteristics and Molecular Structure of Ultrasonic Extraction Derived From Mid-Temperature Pitch[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2022, 42(03): 889-895. |
| [4] |
LI Xue-ping1, 2, 3, ZENG Qiang1, 2, 3*. Development and Progress of Spectral Analysis in Coal Structure Research[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2022, 42(02): 350-357. |
| [5] |
YANG Jiong1, 2, QIU Zhi-li1, 4*, SUN Bo3, GU Xian-zi5, ZHANG Yue-feng1, GAO Ming-kui3, BAI Dong-zhou1, CHEN Ming-jia1. Nondestructive Testing and Origin Traceability of Serpentine Jade From Dawenkou Culture Based on p-FTIR and p-XRF[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2022, 42(02): 446-453. |
| [6] |
HE Xiong-fei1, 2, HUANG Wei3, TANG Gang3, ZHANG Hao3*. Mechanism Investigation of Cement-Based Permeable Crystalline Waterproof Material Based on Spectral Analysis[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(12): 3909-3914. |
| [7] |
ZHOU Jing1,2, ZHANG Qing-qing1,2, JIANG Jin-guo2, NIE Qian2, BAI Zhong-chen1, 2*. Study on the Rapid Identification of Flavonoids in Chestnut Rose (Rosa Roxburghii Tratt) by FTIR[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(10): 3045-3050. |
| [8] |
Samy M. El-Megharbel*，Moamen S. Refat. In First Time: Synthesis and Spectroscopic Interpretations of Manganese(Ⅱ), Nickel(Ⅱ) and Mercury(Ⅱ) Clidinium Bromide Drug Complexes[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(10): 3316-3320. |
| [9] |
Samy M. El-Megharbel*, Moamen S. Refat. Preparations and Spectroscopic Studies on the Three New Strontium(Ⅱ), Barium(Ⅱ), and Lead(Ⅱ) Carbocysteine Complexes[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(09): 2975-2979. |
| [10] |
YU Chun-mei, ZHANG Nan, TENG Hai-peng. Investigation of Different Structures of Coals Through FTIR and Raman Techniques[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(07): 2050-2056. |
| [11] |
QU Li-guo1,2,3, LIU Jian-guo1, XU Liang1*, XU Han-yang1, JIN Ling1, DENG Ya-song1,2, SHEN Xian-chun1, SHU Sheng-quan1,2. Vehicle Exhaust Detection Method Based on Portable FTIR[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(06): 1751-1757. |
| [12] |
Samar O. Aljazzar. Spectroscopic Investigations for the Six New Synthesized Complexes of Fluoroquinolones and Quinolones Drugs With Nickel(Ⅱ) Metal Ion: Infrared and Electronic Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(06): 1976-1981. |
| [13] |
Lamia A. Albedair. Synthesis, Structural, Spectroscopic Characterization and Biological Properties of the Zn(Ⅱ), Cu(Ⅱ), Ni(Ⅱ), Co(Ⅱ), and Mn(Ⅱ) Complexes With the Widely Used Herbicide 2,4-Dichlorophenoxyacetic Acid[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(06): 1982-1987. |
| [14] |
LI Ping1,2, WU Yi-qiang1, LÜ Jian-xiong3, YUAN Guang-ming1, ZUO Ying-feng1*. Effect of Biomimetic Respiration Method on the Impregnation Effect of Silicate Modified Chinese Fir by XPS and FTIR Analysis[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(05): 1430-1435. |
| [15] |
HAO Hui-min1,2, LIANG Yong-guo1,2, WU Hai-bin1,2, BU Ming-long1,2, HUANG Jia-hai1,2*. Infrared Spectrum Recognition Method Based on Symmetrized Dot Patterns Coupled With Deep Convolutional Neural Network[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(03): 782-788. |
|
|
|
|
