Abstract：NOx is the most harmful component for ecological environment in diesel engine emission. As global environmental problem becomes increasingly serious, the NOx emission of diesel engine has been concerned widely. With a variety of emission regulations legalized, this not only presents new demands for NOx emissions of diesel engine but also puts forward higher requirements for test method. Feasible test methods usually are the methods of sampling and analysis, which need a long sampling time and can’t achieve online measure of emission. The online measure of diesel engine emission is not only to the benefit of supervising but also provides data support for optimizing combustion process and optimizing control strategy for diesel engine. Optical detection technique serves as a new detection method. As one of it, the tunable diode laser absorption spectroscopy has been widely applied in other areas because of simple experimental principle and fast response speed. In order to verify the feasibility of this method in diesel engine NOx emissions testing, experimental team researched on the online test of diesel NOx emission by TDLAS. Aiming at the main component of NOx, two interband cascade lasers whose tunable wavelengths were 5 262~5 265 and 6 136~6 142 nm were selected as detecting light source for respectively testing NO and NO2. Thorlabs PDA10JT type thermal detectors were chosen for collecting optical signal. The diesel engine of D4114B by the direct detection was researched and the test result with the result of AVL emission analyzer was compared. The measure error is less than 5％. In addition, experimental team conducted NOx transient emission measurement of a diesel variable conditions with the high time resolution of TDLAS and obtained a reasonable changed consequence of NOx emissions. Thus, appling TDLAS technique has important significance for transient emission characteristics of diesel engine.
Key words：Diesel engine；NOx emission；Spectral absorption；Online test
袁志国，杨晓涛，谢文强，李学民. 基于TDLAS直接检测法的柴油机NOx排放在线测试[J]. 光谱学与光谱分析, 2018, 38(01): 194-199.
YUAN Zhi-guo, YANG Xiao-tao, XIE Wen-qiang, LI Xue-min. Research on the Online Test of Diesel NOx Emission by TDLAS. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2018, 38(01): 194-199.
[1] XIA Yan, LIU Jing-ping, YUAN Zhi-peng(夏 言，刘敬平，袁志鹏). Transactions of CSICE(内燃机学报), 2014, 32(3): 223.
[2] Karaduman I, Er E, Celikkan H. Sensors and Actuators B-Chemical, 2015, 221: 1188.
[3] Kuchekar S R, Pulate S D, Shelar Y S. Indian Journal of Chemical Technology, 2014, 21(2): 120.
[4] CAO Wei, ZENG Li-min, WU Yu-sheng(曹 玮，曾立民，吴宇声). Acta Scientiae Circumstantiae(环境科学学报), 2013, 33(2): 346.
[5] DANG Jing-min, FU Li, YAN Zi-hui, et al(党敬民，付 丽，闫紫徽，等). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2014, 34(10): 2851.
[6] Krzempek K, Jahjah M, Lewicki R. Applied Physics B-Lasers and Optics, 2013, 112(4): 461.
[7] Krzempek K, Lewicki R, Nahle L. Applied Physics B-Lasers and Optics, 2012, 106(2): 251.
[8] Lefkowitz J K, Uddi M, Windom B C. Proceedings of the Combustion Institute, 2015, 35(3): 3505.
[9] Sane A, Satija A, Lucht R P. Applied Physics B-Lasers and Optics, 2014, 117(1): 7.
[10] ZHANG Zhi-rong, DONG Feng-zhong, WU Bian(张志荣，董凤忠，吴 边). Journal of Optoelectronics·Laser(光电子·激光), 2011, 22(11): 1691.
[11] DAI Bin, RUAN Jun, XU Zhen-yu(戴 斌，阮 俊，许振宇). Gas Turbine Experiment and Research(燃气涡轮试验与研究), 2015, 28(4): 49.
[12] WANG Chao, WANG Fei, XING Da-wei(王 超，王 飞，邢大伟). Journal of Combustion Science and Technology(燃烧科学与技术), 2014, 20(2): 176.
[13] YAO Hua, WANG Fei, XU Ting(姚 华，王 飞，许 婷). Thermal Power Generation(热力发电), 2011, 40(11): 42.
