Abstract:ZnO/carbon nanotubes composites were prepared by hydrothermal treatment of the mixture of zinc nitrate and acid-treated multiwalled carbon nanotubes and characterized by transmission electron microscope (TEM) and X-ray powder diffraction (XRD). The TEM image indicated that ZnO nanoparticles with a diameter about 28 nm covered the carbon nanotubes. The XRD pattern shows that ZnO nanoparticles attached to the MWNTs exhibit a hexagonal phase. The diffraction peaks can be assigned to (100), (002), (101), (102), (110), (103), (200), (112) and (201) planes of the crystalline ZnO, respectively. The average size of the crystalline ZnO, calculated from the half-width of the (100) diffraction peak by the Scherrer equation, is 27.8 nm, which accords with the TEM observation. The ZnO/carbon nanotubes composites were used as a photocatalyst under sunlight for the decomposition of azo-dye, which was studied by UV-Vis spectroscopy. The effects of the illumination time, catalyst amount, initial dye concentration and the different structures of the dye on the photocatalytic process were investigated. It was noted that the intensity of the absorption peak corresponding to the azo-dye decreased rapidly at 400 nm during the photolysis process and the decomposition of azo-dye was a quasi-first order reaction. The decomposition rates for azo-dyes such as acid orange, Acid bright red, Acid light yellow are 0.09, 0.28 and 0.22 mg·L-1·min-1,respectively, which maybe resulted from their different functional groups. It can be stated that the complete removal of color, after selection of optimum operation parameters, can be achieved in relatively short time by using ZnO/carbon nanotubes composites. After recycling 5 times, the catalyst still has more than 50% efficiency.
[1] Taborda A V, Brusa M A, Grela M A. Applied Catalysis A: General, 2001, 208: 419. [2] Makarova O V, Rajh T, Thurnaure M C. Environmental Science Technology, 2000, 34: 4797. [3] ZHAO Jin-wei, YUAN Min, LIU Xiao-heng(赵金伟, 袁 敏, 刘孝恒). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2005, 25(10): 1677. [4] CHEN You-cun, ZHANG Yuan-guang(陈友存, 张元广). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2004, 24(9): 1032. [5] ZHANG Li-de, MOU Ji-mei(张立德, 牟季美). Nanomaterials and Nanostructures(纳米材料和纳米结构). Beijing: Science Press(北京: 科学出版社), 2001. 59, 88. [6] DING Shi-wen, ZHANG Shao-yan, LIU Shu-juan, et al(丁士文, 张绍岩, 刘淑娟, 等). Chinese J. Inorg. Chem.(无机化学学报), 2002, 18(10): 1015. [7] Iijima S. Nature, 1991, 354: 56. [8] Ding R G, Lu G Q, Yan Z F, et al. J. Nanosci. Nanotechnol., 2001, 1: 7. [9] Ajayan P. M. Chem. Rev., 1999, 99: 1787. [10] PU Ling-yu, LI Yong-dan(朴玲钰,李永丹). Chemical Industry and Engineering(化工进展), 2001, 20(11): 18. [11] WU Xiao-li, YUE Tao, LU Rong-rong, et al(吴小利, 岳 涛, 陆荣荣, 等). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2005, 25(10): 1595. [12] Planeix J M, Coustel N, Coq B, et al. J. Am. Chem. Soc., 1994, 116: 7935. [13] Xue B, Chen P, Hong Q, et al. J. Mater. Chem., 2001, 11: 2378. [14] Van Steen E, Prinsloo F F. Catal. Today, 2002, 71: 327. [15] Baleizo C, Gigante B, Garcia H, et al. J. Catal., 2004, 221: 77. [16] Li W Z, Liang C H, Zhou W J, et al. Carbon, 2004, 42: 423. [17] Qian W Z, Liu T, Wei F, et al. Carbon, 2003, 41: 846. [18] Li W Z, Liang C H, Qiu J S, et al. Carbon, 2002, 40: 791. [19] Wu H Q, Wei X W, Shao M W, et al. J. Mater. Chem., 2002, 12: 1919. [20] Jiang L Q, Gao L. Mater. Chem. Phys., 2005, 91: 313.