Research on a Novel High-Precision Methane Concentration Detection System
SONG Lin-li1, ZHOU Han-chang1, ZHANG Zhi-jie2
1. National Key Laboratory for Electronic Measurement Technology, North University of China, Taiyuan 030051, China 2. Key Laboratory of Instrumentation Science and Dynamic Measurement, Ministry of Education, North University of China, Taiyuan 030051, China
Abstract:In the gas concentration detection process using the characteristic spectrum absorption method, in order to improve the detection accuracy of the gas concentration, it often has to use the high-quality narrowband modulated laser and modulate wavelength to align with the characteristic absorption peaks of measured gas. But by this way, the cost of the laser and system requirements will be greatly increased. To use the existing portable, low-cost semiconductor laser conditions, at the same time it can obtain higher precision, conversion window differential absorption optical structure and the algorithm of differential characteristic absorption ratio was designed. Selection reason of position of the wavelength characteristic was analyzed, and steps to implement the processing algorithm were given. Systematically utilizing the combination method of conversion window and absorption gas chamber, by the method for calculating the ratio of the light intensity response, the light intensity from non-characteristic absorption peak position was divided out. So it achieved a similar detecting effect was achieved that used a narrow-band laser aligned to the feature absorption peak position. Experiments adopted MW-IR-1650 infrared laser, type SSM17-2 stepper motor control module, C30659 infrared detectors, and other devices. In the experiments, different concentrations of methane gas were tested, and experimental results show that the relative error of measurement was less than 2.0% within the range from 200 to 5 000 ppm. In summary, it’s proved that the system has high accuracy and stability.
Key words:Spectroscopy;Differential ratio algorithm;Characteristic absorption conversion window;Methane concentration
[1] ZHANG Ying, WANG Hai-rong, GAO Xian-ni(张 英, 王海容, 高鲜妮). Piezoelectectrics & Acoustooptics(压电与声光), 2008, 30(2): 156. [2] YAN Jie, MENG Peng-hua(闫 洁, 孟鹏花). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2013, 33(8): 2153. [3] WANG Yan-ju, WANG Yu-tian, ZHANG Yu-yan(王艳菊, 王玉田, 张玉燕). Chinese Journal of Scientific Instrument(仪器仪表学报), 2006, 27(12): 1647. [4] ZHAO Ling, HE Xiu-li, JIA Jian(赵 玲, 何秀丽, 贾 建). Instrument Technique and Sensor(仪表技术与传感器), 2014, (2): 50. [5] WU Xi-jun, WANG Yu-tian, TIAN Rui-ling(吴希军, 王玉田, 田瑞玲). Chinese Journal of Sensors and Actuators(传感技术学报), 2010, 23(1): 14. [6] Cihelka J, Civis S, Matulkova I. ICTON Mediterranean Winter Conference, 2007, (1): 1. [7] Angelmahr M, Miklós A, Hess P. Applied Physics B: Lasers and Optics, 2006, 85(2-3): 285. [8] Kim Min-Soo, Lee Sang-Kwon. Journal of Loss Prevention in the Process Indusuries, 2009, 22(6): 990. [9] Curti F, Matera F, Tosi-Beleffi G M. International Conferences on Transparent Optical Networks, 2002, (1): 66. [10] WANG Yu-tian, LIU Jin, YANG Hai-ma(王玉田, 刘 瑾, 杨海马). Chinese Journal of Sensors and Actuators(传感技术学报), 2003, 16(3): 324. [11] Acosta Eva, Chamadoira Sara, Blendowske Ralf. Journal of the Optical Society of America, 2006, 23(3): 632. [12] Katie M Krause, Jerome Genest. Applied Optics, 2006, 45(19): 4686. [13] LI Li, ZHANG Yu, SONG Zhen-yu(李 黎, 张 宇, 宋振宇). Infrared(红外), 2007, 28(9): 29.