Determination of Cationic Degree in PDA with Near Infrared Reflectance Spectroscopy
ZHENG Huai-li1, ZHANG Peng1, CHEN Yu-zhe1, TAN Ming-zhuo2, JIANG Shao-jie1, ZHU Chuan-jun3, ZHU Guo-cheng1, MA Jiang-ya1, ZHANG Zhao-qing1
1. Key Laboratory of the Three Gorges Reservoir Region Eco-Environment of Ministry of Education, Chongqing University, Chongqing 400045, China 2. Jiangmen Wealth Water Purifying Agent Co., Ltd., Jiangmen City, Jiangmen 529000, China 3. Tianjin Chemical Research and Design Institute, Tianjin 300131, China
Abstract:Cationic degree has been investigated as an important factor in polyacrylamide materials. Diallyl dimethyl ammonium chloride and acrylamide (PDA) was grafted by free radical polymerisation of acrylamide monomer (AM) onto the cationic monomer dimethyl diallyl ammonium chloride (DMDAAC). In the present study, near infrared reflectance spectroscopy(NIRS) was used as a rapid and accurate method to determine the cationic degree in the PDA. In this experiment, the near infrared spectra of 37 PDA samples that were self-prepared in the laboratory from 900.00 to 1 700.00 were collected. The characteristic peaks and the entire spectrum segment as the input layer neurons in radical basis function(RBF) were investigated for establishing the mathematical conversion NIRS calibration mode. For reduction of the NIR spectrum noise, the wavelet analysis was used as pretreatment process. The measured value was determined by using precipitation titration and a comparison between the simulated value and measured value was made. It was found that the external validation determination coefficient was more than 0.9, and the simulation value is in good agreement with the measured value. The statistics analysis showed that there was no significant difference between simulated value and measured value. Therefore, the calibration model (RBF neural network) established in this paper exhibited a remarkable feasibility for predicting the cationic degree of PDA based on the near infrared spectroscopy.
Key words:PDA;Cationic degree;Near infrared reflectance spectroscopy;Wavelet analysis;Radical basis function (RBF)
[1] Singh A, Singh N P, Singh P, et al. Journal of Polymer Research, 2011, 18: 67. [2] Dolphen R, Sakkayawong N, Thiravetyan P, et al. Journal of Hazardous Materials, 2007, 145: 250. [3] Kyzas G Z, Kostoglou M, Lazaridis N K. Chemical Engineering Journal, 2009, 152: 440. [4] ZHENG Huai-li, SUN Xiu-ping, HE Qiang, et al. Journal of Applied Polymer Science, 2008, 11(4): 2464. [5] ZHENG Huai-li, TANG Xue, SHEN Lie-xiang, et al(郑怀礼, 唐 雪, 沈烈翔, 等). Journal of Chongqing University (重庆大学学报), 2010, 33(7): 115. [6] FANG Yue-mei(方月梅). Chinese Journal of Environmental Engineering(环境工程学报), 2009, 3(11): 2021. [7] ZHAO Song-mei, LIU Kun-yuan (赵松梅, 刘昆元). Journal of Beijing University of Chemical Technology(北京化工大学学报), 2005, 32(4): 29. [8] Losada R, Wandrey C. Macromolecules, 2009, 42: 3285. [9] Barajas J H, Hunkeler D, Wandrey C H. Polymer News, 2004, 29: 239. [10] Stobiecka A, Radecka H, Radecki J. Biosensors and Bioelectronics, 2007, 22: 2165. [11] Gaitan-Jurado A, Garcta-Molina M, Pena-Rodriguez F, et al. Journal of Near-Infrared Spectroscopy, 2008, 16(4): 421. [12] CHEN Quan-sheng, GUO Zhi-ming, ZHAO Jie-wen, et al(陈全胜, 郭志明, 赵杰文, 等). Journal of Infrared and Millimeter Waves(红外与毫米波学报), 2009, 28(5): 357. [13] ZHENG Huai-li, ZHU Guo-cheng, JIANG Shao-jie, et al. Desalination, 2011, 269: 148.