Optimization of Online Determination Model for Sugar in a Whole Apple
Using Full Transmittance Spectrum
TIAN Xi1, 2, 3, CHEN Li-ping2, 3, WANG Qing-yan2, 3, LI Jiang-bo2, 3, YANG Yi2, 3, FAN Shu-xiang2, 3, HUANG Wen-qian2, 3*
1. College of Information and Electrical Engineering, China Agricultural University, Beijing 100083, China
2. Intelligent Equipment Research Center, Beijing Academy of Agriculture and Forestry Sciences, Beijing 100097, China
3. Information Technology Research Center, Beijing Academy of Agriculture and Forestry Sciences, Beijing 100097, China
Abstract：In Vis/NIR nondestructive detection, the accuracy of the prediction model is affected by many factors such as spectral quality, biological variability, detection system and modeling method. In this study, the multi-point full-transmittance spectra (650~1 000 nm) of “Fuji” apple were acquired at a speed of 0.5 m·s-1 with an integration time of 0.5 ms using an on-line spectrum measurement system. The spectral intensity changed with the detection orientations significantly, but the spectral curves of different orientations were similar, with an obvious peak at 920 nm and an obvious valley at 850 nm. To establish a reliable, accurate, and stable sugar calibration model of intact apple, three spectra preprocessing methods, including moving average smoothing, standard normal variate, and multiplicative scatter correction (MSC), were used to reduce the influence of noise from the environment and instrumental fluctuations. In order to analyze the effect of detection orientations on prediction accuracy, a local model based on single orientation and a universal model based on global orientations were built respectively. The result showed that the prediction accuracy was limited by the detection orientation in the local model, while the universal model had better applicability for multiple detection orientation than that of the local model. In order to further improve the prediction ability, a modeling method named efficient spectrum optimization was proposed to select the spectra with a high signal-to-noise ratio and remove the inefficient transmittance spectrum by investigating the interference of transmittance spectral intensity on the accuracy of the prediction model. The result showed that it is beneficial to optimize the prediction model after removing the spectrum collected from the central zone of the apple. The universal intensity optimization model considered the spectral quality of different orientations comprehensively. The prediction model was best with Rp,RMSEP and RPD of 0.79，0.84% and 1.58 respectively, when the spectral intensity threshold was 5 000. Our result illustrated that the multi-potion spectrum measurement system is promising for on-line detection of apple quality. The modeling method of efficient spectrum optimization could be selective the transmittance spectrum with a high signal-to-noise ratio and optimize the prediction model.
田 喜，陈立平，王庆艳，李江波，杨 一，樊书祥，黄文倩. 全透射近红外光谱的苹果整果糖度在线检测模型优化[J]. 光谱学与光谱分析, 2022, 42(06): 1907-1914.
TIAN Xi, CHEN Li-ping, WANG Qing-yan, LI Jiang-bo, YANG Yi, FAN Shu-xiang, HUANG Wen-qian. Optimization of Online Determination Model for Sugar in a Whole Apple
Using Full Transmittance Spectrum. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2022, 42(06): 1907-1914.
[1] Tian X，Fan S，Li J，et al. Infrared Physics & Technology，2019, 102：102979.
[2] Zhang B，Gu B，Tian G，et al. Trends in Food Science & Technology，2018, 81：213.
[3] LIU Yan-de，XU Hai，SUN Xu-dong，et al（刘燕德，徐 海，孙旭东，等）. Spectroscopy and Spectral Analysis（光谱学与光谱分析），2020，40（3）：922.
[4] Bai Y, Xiong Y, Huang J, et al. Postharvest Biology and Technology，2019，156：110943.
[5] Fan S，Guo Z，Zhang B，et al. Food Analytical Methods，2016，9（5）：1333.
[6] Xia Y，Huang W，Fan S，et al. Infrared Physics & Technology，2019，97：467.
[7] Tian X，Li J，Wang Q，et al. Food Chemistry，2018，（239）：1055.
[8] Guo Z，Huang W，Peng Y，et al. Postharvest Biology and Technology，2016，（115）：81.
[9] WANG Fan, LI Yong-yu, PENG Yan-kun, et al（王 凡，李永玉，彭彦昆，等）. Transactions of the Chinese Society of Agricultural Engineering（农业工程学报）, 2017, 33(19): 295.
[10] GUO Zhi-ming, CHEN Quan-sheng, ZHANG Bin, et al（郭志明，陈全胜，张 彬，等）. Transactions of the Chinese Society of Agricultural Engineering（农业工程学报）, 2017, 33(8): 253.
[11] Yu X, Lu Q, Gao H, et al. Journal of Near Infrared Spectroscopy, 2016, 24(1): 69.
[12] Fan S, Wang Q, Tian X, et al. Biosystems Engineering, 2020, 193: 138.
