光谱学与光谱分析 |
|
|
|
|
|
Preparation of MgxZn1-xO /Au/MgxZn1-xO Multilayer Transparent Conductive Film and Studies of Its Photoelectric Properties |
Lü Shan-shan1, FANG Xuan1*,WANG Jia-qi1, FANG Fang1,ZHAO Hai-feng2, CHU Xue-ying1, LI Jin-hua1, FANG Dan1, TANG Ji-long1, WEI Zhi-peng1, MA Xiao-hui1, WANG Xiao-hua1*, PU Shuang-shuang1, XU Li1 |
1. State Key Laboratory of High Power Semiconductor Laser, School of Science, Changchun University of Science and Technology,Changchun 130022, China 2. Key Laboratory of Excited State Process, Changchun Institute of Optics, Fine Mechanics and Physics, Chinese Academy of Science, Changchun 130033, China |
|
|
Abstract In the present paper, MgxZn1-xO and MgxZn1-xO/Au/MgxZn1-xO multilayer structures of transparent conductive film were prepared by the simple operation of sol-gel and RF magnetron sputtering method on quartz substrate respectively and then they were annealed. The surface, electrical, crystal and optical properties of the films at different annealing temperature were determined by UV-Vis spectrophotometer, X-ray diffraction, photoluminescence and Hall effect, respectively. The influence of annealing temperature on the films was also investigated. The testing results indicated that the films with good c-axis orientation presented hexagonal wurtzite structure. With increasing Mg components, the optical band gap of ZnO thin film increased gradually. There was an obvious blue shift phenomenon in PL spectrum and absorption spectrum line. But the electrical properties of the films declined. In MgxZn1-xO/Au/MgxZn1-xO multilayer structure of thin film samples, the existence of Au interlining led to the poor optical properties of thin film, and the light transmittance in the ultraviolet region was 60%. Compared with MgxZn1-xO film, the electrical properties of MgxZn1-xO/Au/MgxZn1-xO multilayer structure of transparent conductive film were improved, the resistivity and migration rate were significantly increased. In addition, high temperature annealing treatment could effectively improve the crystal quality of thin film and further improve the electrical characteristics of the samples. After the annealing treatment at 500 ℃, migration rate of the film reached to 40.9 cm2·Vs-1 while the resistivity was 0.005 7 Ω·cm. Due to the rising of temperature, the crystal size increased from 25.1 to 32.4 nm to reduce the mobility of the film. Therefore, MgxZn1-xO/Au/MgxZn1-xO multilayer structure of transparent conductive film played an important role in promoting the ZnO transparent conductive film application in deep ultraviolet devices.
|
Received: 2014-04-01
Accepted: 2014-06-28
|
|
Corresponding Authors:
FANG Xuan, WANG Xiao-hua
E-mail: fangxuan110@hotmail.com; biewang2001@126.com
|
|
[1] Dong X, Wang H, Wang J, et al. Applied Mechanics and Materials, 2012, 130: 1192. [2] LIU Kai, ZHAO Xiao-ru, ZHAO Liang, et al(刘 凯, 赵小如, 赵 亮, 等). J. Synth. Cryst.(人工晶体学报),2009, 38: 585. [3] Zhang F L, Gadisa A, Inganas O, et al. Appl. Phys. Lett., 2004, 84:3906. [4] Li Y, Meng J. Mater Lett., 2014, 117: 260. [5] Luna-Arredondo E J, Maldonado A, Asomoza R, et al. Thin Solid Films, 2005, 490: 132. [6] Huang K, Tang Z, Zhang L, et al. Appl. Surf, Sci., 2012, 258: 3710. [7] Euvananont C, Pakdeesathaporn S, Pratoomwan P, et al. Journal of Microscopy Society of Thailand, 2008,22:26. [8] Kim G H, Du Ahn B, Shin H S, et al. Appl. Phys. Lett., 2009, 94: 233501. [9] Tsay C Y, Wu C W, Lei C M, et al. Thin Solid Films, 2010, 519(5): 1516. [10] Kim H K, Yi M S, Lee S N. Thin Solid Films, 2009, 517: 4039. [11] Tsay C Y, Cheng H C, Tung Y T, et al. Thin Solid Films, 2008, 517(3): 1032. [12] Jeong J A, Park Y S, Kim H K. J. Appl. Phys., 2010, 107: 023111. [13] HUANG Kai, Lü Jian-guo,LIU Xian-song,et al(黄 凯, 吕建国, 刘先松, 等). J. Synth. Cryst.(人工晶体学报), 2010, 39: 1171. [14] Cimpoiasu A, Van Der Pers N M, de Keyser T H, et al. Smart Materials and Structures, 1996, 5: 744. [15] Lin L Y, Kim D E. Thin Solid Films, 2009, 517: 1690. [16] LI Ya-ling, LI Wen-bo, LI Mi-shan, et al(李亚玲, 李文博, 李宓善, 等). College Physics(大学物理), 2005, 24: 30. [17] Peng L P, Fang L, Yang X F, et al. J. Alloy Compd., 2009, 484: 575. [18] Cao L, Zhu L, Jiang J, et al. J. Alloy Compd., 2012, 516: 157. [19] Liu K W, Tang Y D, Cong C X, et al. Appl. Phys. Lett., 2009, 94: 151102. [20] Xu L, Li X, Chen Y, et al. Appl. Surf. Sci., 2011, 257: 4031. [21] WU Xiao-li, CHEN Chang-le, HAN Li-an, et al(吴小丽, 陈长乐, 韩立安, 等). Acta Physica Sinica(物理学报), 2008, 57: 3735. [22] Girtan M, Folcher G. Surface and Coatings Technology, 2003, 172: 242. [23] ZHANG Shi-kai, ZHANG Bao-lin, SHI Zhi-feng, et al(张仕凯, 张宝林, 史志锋). Chin. J. Lumin.(发光学报), 2012, 33: 934. |
[1] |
YUAN Kai-xin, ZHUO Jin, ZHANG Qing-hua, LI Ya-guo*. Study on the Spectral and Laser Damage Resistance of CO2 Laser Modified Sol-Gel SiO2 Thin Films[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(06): 1752-1759. |
[2] |
YANG Chang-hu, YUAN Jian-hui. Effects of Thickness on Spectral Properties of Undoped ZnO Thin Films[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(09): 2835-2838. |
[3] |
QIU Zhi-che, GU Mu*, LIU Xiao-lin, LIU Bo, HUANG Shi-ming, NI Chen . Preparation and Performances of the M′-Type LuTaO4∶Eu3+ Transparent Scintillator Films[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2016, 36(02): 336-339. |
[4] |
GUO Yu, JIN Yu-jia, WU Hong-mei, LI Dong-xin . Preparation and Photocatalytic Properties of Supported TiO2 Photocatalytic Material[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2015, 35(06): 1677-1681. |
[5] |
SUN Dong-xiao1, LI Jin-hua1*, FANG Xuan1, 2, CHEN Xin-ying1, FANG Fang1, CHU Xue-ying1, WEI Zhi-peng1, 2, WANG Xiao-hua1. Effects of Annealing Temperature on the Structure and Optical Properties of ZnMgO Films Prepared by Atom Layer Deposition [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2014, 34(07): 1789-1792. |
[6] |
SHANG Meng-ying1, 2, 3, CAO Lin-hong2, 3, LIU Miao1, LUO Xuan1, REN Hong-bo1, YE Xin1, TANG Yong-jian1, JIANG Xiao-dong1*. Study on the Preparation and Properties of Novel Silica Microporous Antireflective Coating by Sol-Gel Process[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2013, 33(04): 872-876. |
[7] |
YIN Ming, ZHANG Xin-ping*, LIU Hong-mei. Effect of Annealing Temperature on the Crystallization and Spectroscopic Response of a Small-Molecule Semiconductor Doped in Polymer Film [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2012, 32(11): 3078-3082. |
[8] |
WANG Xi-gui,QI Xia,BO Su-ling,NA Mi-la . Preparation and Luminescence Properties of Nanomaterials TiO2—SiO2 Doped with Eu3+ [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2011, 31(05): 1193-1196. |
[9] |
WU Yang, WANG Yong-sheng*, HE Da-wei*, FU Ming, CHEN Zhen-min, LI Yue, MIAO Feng . Synthesis of the Zn2SiO4∶Eu3+ Red Phosphor by Sol-Gel Method [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2011, 31(04): 890-893. |
[10] |
FAN Yang-yang, LIU Xiao-lin*, GU Mu, NI Chen, HUANG Shi-ming, LIU Bo . Modification and Luminescence Properties of Transparent Lu2SiO5∶Ce3+ Thin-Film Phosphors [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2011, 31(02): 344-348. |
[11] |
PAN Jing1, HU Xiao-yun1*, LIU Guo-jing1, ZHANG De-kai1, FAN Jun2 . Influence of the Amount of H2O on the Emission Spectra of Tb Doped SiO2 Xerogels [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2010, 30(05): 1179-1183. |
[12] |
GU Mu, ZHOU Feng, LIU Xiao-lin, NI Chen, HUANG Shi-ming, LIU Bo . Preparation and Luminescence Properties of Transparent Gd2O3∶Eu Thick Film [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2010, 30(03): 603-606. |
[13] |
LIU Wan-bing1, DENG Jian1*, ZHAO Yu-bao1, XU Jin-sheng2, ZHOU Liang1 . Preparation, Spectral Analysis and Photocatalytic Activities of TiO2 Films Codoped with Iron and Nitrogen [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2009, 29(05): 1394-1397. |
[14] |
LIU Quan-sheng,ZHANG Xi-yan*,BAI Zhao-hui,WANG Xiao-chun,MI Xiao-yun,LU Li-ping,ZHOU Ying . Preparation and Characterization of MgxZn1-xO Powders[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2009, 29(04): 901-903. |
[15] |
FENG Shi-hong1,JIA Tai-xuan2,3,LIU Zi-li2,3*. Preparation of Mo-Fe Catalysts by Sol-Gel Method and Its XRD, FTIR Spectral Analysis[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2009, 29(02): 548-550. |
|
|
|
|