| 光谱学与光谱分析 |
|
|
|
|
|
| The Preparation and Characterization of 1-D Orderly ZnO Nanorod Arrarys |
| LIU Ran,ZHANG Ting*,ZHAO Su-ling,XU Zheng,ZHANG Fu-jun,YUAN Guang-cai,XU Xu-rong |
| Institute of Optoelectronics Technology, Beijing Jiaotong University, Key Laboratory of Luminescence and Optical Information (Beijing Jiaotong University), Ministry of Education, Beijing 100044，China |
|
|
|
|
Abstract Improving on the sealing and high pressure conditions of traditional hydrothermal method, vertical ZnO nanorod arrays were synthesized on indium tin oxide substrate by employing Zn(NO3)2·6H2O, (CH2)4N6 as the starting materials in the presence of polyethylenimine(PEI) at ambient pressure and low temperature (92°). Between the substrate and the nanorods, a layer of ZnO flim was prepared as buffer layer and seed layer. The ZnO film was gained by spin-coating zinc acetate solution on indium tin oxide substrate, then annealed at 350 ℃ for 20 min, which can make zinc acetate decompose into zinc oxide. The zinc acetate spin-coating and decomposition procedure was carried out twice to ensure a complete and uniform coverage of ZnO seeds. The second layer was annealed at 500 ℃ for 30 min. Different spin-coating speeds were adopted, one was 2 500 r·min-1,and the other was 5 000 r·min-1. XRD result indicated that the seed layer with 5 000 r·min-1 has better alignment than the layer with 2 500 r·min-1. The aligned seeds with 5 000 r·min-1 show only a (002) reflection, indicating their complete c-axis texturing, whereas the spin-coated seeds give a powder pattern because they rest at all angles on the substrate. SEM result shows that the layer is made up of grains with an the average size of about 30 nm. Well-aligned ZnO nanorod arrays were synthesized by putting the substrate with ZnO seeds into the precursor solutions vertically for one hour. The nanorod arrays were taken out and rinsed with clean ethanol and pure-water for several times, blown dry with a stream of nitrogen, then annealed at 400 ℃ for 30 min in order to wipe off the organic solvent. At room-temperature, the SEM and XRD were measured. SEM results indicate that the crystal structure of most of ZnO nanorods is hexagonal wurtzite crystallographic phase structure, mainly vertical to the substrate. ZnO nanorods have good crystallization, the diameter of the rods is around 40 nm, and the length is above micrometer. The XRD results showed the nanorod arrays have (002) and (004) angles, and the (002) is quite strong. Absorption spectra of the nanorod arrays shows ZnO essence absorption and strong ultraviolet absorption, indicating that ZnO has good quality. Optical properties were studied, and the excitation spectra of the nonorod arrays showed a strong and narrow peak at 387 nm with FWHM smaller than 30 nm and a weak blue peak.
|
|
Received: 2007-07-10
Accepted: 2007-10-18
|
|
|
|
Corresponding Authors:
ZHANG Ting
E-mail: zhangt2003@126.com
|
|
[1] Duan X, Huang Y, Cui Y, et al, et al. Nature(London),2001, 409: 66.
[2] Huang M H, Mao S, Feick H, et al. Science,2001,292: 1897.
[3] LI Hai-ling, WANG Yong-sheng, TENG Feng, et al(李海玲，王永生，滕 枫，等). Spectroscopy and Spectral Analysis(光谱学与光谱分析)，2004，24(10)：1172.
[4] Beermann N, Vayssieres L, Lindquist S E, et al. J. Electrochem. Soc.,2000, 147: 2456.
[5] Zhu Y W, Zhang H Z, Sun X C, et al. Appl. Phys. Lett.,2003, 83: 144.
[6] Yan M, Zhang H T, Widjaja E J, et al. J. Appl. Phys.,2003, 94: 5240.
[7] Wu J J, Liu S C. Adv. Mater.,2002, 14: 215.
[8] Wu J J, Liu S C. J. Phys. Chem. B,2002, 106: 9546.
[9] Liu R, Vertegel A A, Bohannan E W, et al. Chemistry of Materials,2001, 13: 508.
[10] Govender K, Boyle D S, Brien P O, et al. Adv. Mater.,2002, 14: 1221.
[11] Vayssieres L. Adv. Mater.,2003, 15: 464.
[12] Yamabi S, Imai H. J. Mater. Chem.,2002, 12: 3773.
[13] Greene L E, Law M, Goldberger J, et al. Angew. Chem. Internation Edition Chem.,2003, 42(26): 3031.
[14] Greene L E, Law M, Goldberger J, et al. Angewandte Chemie,2003, 115: 3139.
[15] Law M, Greene L E, Goldberger J, et al. Nature Mater.,2005, 4: 455.
[16] LIU Hong-xia, ZHOU Sheng-ming, LI Shu-zhi, et al(刘红霞，周圣明，李抒智, 等). Acta Phys. Sin.(物理学报),2006, 55: 1388.
[17] CHEN Jian-gang, GUO Chang-xin, ZHANG Lin-li, et al(陈建刚，郭常新，张琳丽，等). Chin. J. Luminescence(发光学报),2005,26: 83.
[18] Zhang J, Sun L D, Liao C S, et al. Chemical Communication,2002, (3): 262.
[19] Wang Z L. J. Phys.: Condens. Matter.,2004, 16: R829.
[20] Ohashi N, Sekiguchi T, Aoyama K, et al. J. Appl. Phys.,2002, 91: 3658.
[21] SUN Ping, XIONG Bo, ZHANG Guo-qing, et al(孙 萍，熊 波，张国青，等). Spectroscopy and Spectral Analysis(光谱学与光谱分析)，2007，27(1)：143. |
| [1] |
YANG Xiu-li1, CUI Xiao-yu1, CUI Chong1*, MA Hai-long2, YANG Qing1 . Study on High-Temperature Phase Change of Tobermorite [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2013, 33(08): 2227-2230. |
| [2] |
LIANG Xiao-feng1，2, YIN Guang-fu1*，YANG Shi-yuan2, MA Guo-hua2, WANG Jun-xia2 . Raman Spectra Analysis of Calcium Metaphosphate Glass-Ceramics [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2010, 30(10): 2667-2670. |
| [3] |
GONG Hua1, ZHAO Xin2, YU Xiao-bo1, Setsuhisa Tanabe3, LIN Hai1* . Optical and Spectral Parameters in Ce3+-Doped Gadolinium Gallium Aluminum Garnet Glass-Ceramics[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2010, 30(01): 128-132. |
| [4] |
ZHANG Wen-cheng1,2,ZHANG Xing-yuan2,PAN Jian1. Test of the Effect of Different Supercritical Pressure on Andrographolide Crystallization with Chromatography and Spectrum[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2007, 27(08): 1657-1660. |
| [5] |
YOU Zhen-yu1, TU Chao-yang1*, ZHU Zhao-jie1, LI Jian-fu1, WEI Min1, Alain Brenier2 . Study on the Growth and Spectral Characteristics of LiNbO3:Cr:ZnO Crystal [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2006, 26(01): 1-5. |
| [6] |
HU Tao, LU Xin, YAN Yan, FU Yun-yi, ZHANG Han, ZHANG Shu-lin . Raman Spectroscopic Study on the Iron Oxide Film Prepared by Iron Oxidation Method [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2004, 24(09): 1072-1074. |
|
|
|
|
