|
|
|
|
|
|
Study of the Rapid Measurement of COD by Laser-Induced Breakdown Spectroscopy |
ZHAO Xian-de1,2, CHEN Xiao2, DONG Da-ming2* |
1. College of Information and Electrical Engineering, China Agricultural University, Beijing 100083, China
2. Beijing Research Center of Intelligent Equipment for Agriculture, Beijing 100097, China |
|
|
Abstract Chemical Oxygen Demand (COD) is an important water quality parameter, which is generally used to reflect the degree of organic pollution. The detection of COD has long relied on laboratory chemical analysis methods after sampling. The most commonly used method is potassium dichromate oxidation and acid Potassium Permanganate oxidation. However, the chemical analysis methodsarecomplicated, time-consuming and labor-intensive. Moreover, the introduction of new chemicals by these methods causes secondary pollution. Therefore, there is an urgent need for a detection technique that enables rapid measurement of COD in water. Based on the previous research, the test method of COD by the laser-induced breakdown spectroscopy was explored in this paper. The focus was to optimize the model prediction speed in order to study therapid measurement of COD in waterbythe techniqueof laser-induced breakdown spectroscopy. We collected 99 water samples with different COD concentrations, and divided them into two groups: training set and testing set. The COD concentration of each water sample was measured by potassium dichromate oxidation method. And the spectral information of each water sample at the wavelengths of 200~1 000 nm was collected by the laser-induced breakdown spectroscopy acquisition system built by our laboratory. Partial least squares (PLS) algorithm was used to establish a quantitative measurement model for COD of training set samples and the spectral data of test set were predicted. The predicted results were compared with the real values measured by laboratory chemical methods to evaluate the predicted results. By analyzing the prediction model established by the original spectrum, it was found that a large number of laser-induced breakdown spectral data have poor correlation with COD concentration during the modeling process, and these useless data participated in the calculation, wasting computing resources, dragging the detection time, causing the system load to be too large, which was not conducive to the development of portable detection equipment. We focused on the first few principal components with the largest contribution. By analyzing the principle of COD measurement and the load of PLS model, we found the main characteristic peaks of LIBS spectrum which have the highest correlation with the concentration of COD in water. These characteristic peaks belong to C, H, O, N and some reductive ion elements in water. Most of C, H, O and N come from organic matter in water whose characteristic peaks have the greatest contribution to the prediction ability of COD model. The definition of COD reflects the amount of these elements in the water body, which is consistent with our analysis conclusion. In order to improve the detection speed, we extracted these characteristic peaks, and eliminated a large number of unrelated or low-correlation data. After many times of screening and dimensionality reduction, the original 13 622 data of each spectrum were reduced to 28, which greatly reduced the computational complexity of the system, but still retains good prediction ability. The 28 characteristic wavelengths selected are the best ones to reflect the concentration of COD in water, which lays a foundation for the development of portable multi-band detection equipment for COD in water and the rapid measurement of COD.
|
Received: 2018-08-15
Accepted: 2018-12-20
|
|
Corresponding Authors:
DONG Da-ming
E-mail: dongdm@nercita.org.cn
|
|
[1] Goh C P, Lim P E. Asean Journal on Science and Technology for Development, 2017, 25(2): 383.
[2] ZHANG Ji-hua(张继华). Environmental Science and Technology(环境科学与技术), 2004, 27(8): 37.
[3] YUAN Han-hong, HU Yan-ping, QI Hui-liang(袁汉鸿, 胡艳平, 戚惠良). Water Purification Technology(净水技术), 2005, 24(4): 67.
[4] LUO Guo-bing(罗国兵). Rock and Mineral Analysis(岩矿测试), 2013, 32(6): 860.
[5] Pan T, Chen Z, Chen J, et al. Analytical Methods, 2012, 4(4): 1046.
[6] Fortes F J, Moros J, Lucena P, et al. Analytical Chemistry, 2013, 85(2): 640.
[7] Zhang D C, Hu Z Q, Su Y B, et al. Optics Express, 2018, 26(14): 18794.
[8] Costa V C, Aquino F W B, Paranhos C M, et al. Polymer Testing, 2017, 59: 390.
[9] Hoehse M, Paul A, Gornushkin I, et al. Analytical & Bioanalytical Chemistry, 2012, 402(4): 1443.
[10] Janzen C, Fleige R, Noll R, et al. Spectrochimica Acta Part B, Atomic Spectroscopy, 2005, 60(7): 993.
[11] Bilge G, Sezer B, Boyaci I H, et al. Spectrochimica Acta Part B, Atomic Spectroscopy, 2018, 145.
[12] Mousavi S J, Farsani M H, Darbani S M R, et al. Applied Physics B, 2016, 122(5): 1.
[13] YE Song, GU Ya-hui, DU Xiao-fan, et al(叶 松, 顾亚辉, 杜晓凡, 等). Spectroscopy and Spectral Analysis(光谱学与光谱分析),2017, 37(11): 3585. |
[1] |
LI Yu1, ZHANG Ke-can1, PENG Li-juan2*, ZHU Zheng-liang1, HE Liang1*. Simultaneous Detection of Glucose and Xylose in Tobacco by Using Partial Least Squares Assisted UV-Vis Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2024, 44(01): 103-110. |
[2] |
LIU Jia1, 2, GUO Fei-fei2, YU Lei2, CUI Fei-peng2, ZHAO Ying2, HAN Bing2, SHEN Xue-jing1, 2, WANG Hai-zhou1, 2*. Quantitative Characterization of Components in Neodymium Iron Boron Permanent Magnets by Laser Induced Breakdown Spectroscopy (LIBS)[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2024, 44(01): 141-147. |
[3] |
ZHANG Nan-nan1, 3, CHEN Xi-ya1,CHANG Xin-fang1, XING Jian1, GUO Jia-bo1, CUI Shuang-long1*, LIU Yi-tong2*, LIU Zhi-jun1. Distributed Design of Optical System for Multi-Spectral Temperature
Pyrometer[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2024, 44(01): 230-233. |
[4] |
ZHANG Ning-chao1, YE Xin1, LI Duo1, XIE Meng-qi1, WANG Peng1, LIU Fu-sheng2, CHAO Hong-xiao3*. Application of Combinatorial Optimization in Shock Temperature
Inversion[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(12): 3666-3673. |
[5] |
YANG Wen-feng1, LIN De-hui1, CAO Yu2, QIAN Zi-ran1, LI Shao-long1, ZHU De-hua2, LI Guo1, ZHANG Sai1. Study on LIBS Online Monitoring of Aircraft Skin Laser Layered Paint Removal Based on PCA-SVM[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(12): 3891-3898. |
[6] |
BAI Bing1, 2, 3, CHEN Guo-zhu2, 3, YANG Wen-bin2, 3, CHE Qing-feng2, 3, WANG Lin-sen2, 3, SUN Wei-min1*, CHEN Shuang1, 2, 3*. The Study on Precise and Quantitative Measurement of Flame OHConcentration by CRDS-CARS-PLIF Techniques[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(12): 3955-3962. |
[7] |
SHEN Ying, WU Pan, HUANG Feng*, GUO Cui-xia. Identification of Species and Concentration Measurement of Microalgae Based on Hyperspectral Imaging[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(11): 3629-3636. |
[8] |
SUN Cheng-yu1, JIAO Long1*, YAN Na-ying1, YAN Chun-hua1, QU Le2, ZHANG Sheng-rui3, MA Ling1. Identification of Salvia Miltiorrhiza From Different Origins by Laser
Induced Breakdown Spectroscopy Combined with Artificial Neural
Network[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(10): 3098-3104. |
[9] |
LIU Shu1, JIN Yue1, 2, SU Piao1, 2, MIN Hong1, AN Ya-rui2, WU Xiao-hong1*. Determination of Calcium, Magnesium, Aluminium and Silicon Content in Iron Ore Using Laser-Induced Breakdown Spectroscopy Assisted by Variable Importance-Back Propagation Artificial Neural Networks[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(10): 3132-3142. |
[10] |
JIA Hao1, 3, 4, ZHANG Wei-fang1, 3, LEI Jing-wei1, 3*, LI Ying-ying1, 3, YANG Chun-jing2, 3*, XIE Cai-xia1, 3, GONG Hai-yan1, 3, DING Xin-yu1, YAO Tian-yi1. Study on Infrared Fingerprint of the Classical Famous
Prescription Yiguanjian[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(10): 3202-3210. |
[11] |
LIU Wen-bo, LIU Jin, HAN Tong-shuai*, GE Qing, LIU Rong. Simulation of the Effect of Dermal Thickness on Non-Invasive Blood Glucose Measurement by Near-Infrared Spectroscopy[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(09): 2699-2704. |
[12] |
LI Chang-ming1, CHEN An-min2*, GAO Xun3*, JIN Ming-xing2. Spatially Resolved Laser-Induced Plasma Spectroscopy Under Different Sample Temperatures[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2032-2036. |
[13] |
ZHAO Yang1, ZHANG Lei2, 3*, CHENG Nian-kai4, YIN Wang-bao2, 3*, HOU Jia-jia5, BAI Cheng-hua1. Research on Space-Time Evolutionary Mechanisms of Species Distribution in Laser Induced Binary Plasma[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2067-2073. |
[14] |
LUO Dong-jie, WANG Meng, ZHANG Xiao-shuan, XIAO Xin-qing*. Vis/NIR Based Spectral Sensing for SSC of Table Grapes[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2146-2152. |
[15] |
WANG Bin1, 2, ZHENG Shao-feng2, GAN Jiu-lin1, LIU Shu3, LI Wei-cai2, YANG Zhong-min1, SONG Wu-yuan4*. Plastic Reference Material (PRM) Combined With Partial Least Square (PLS) in Laser-Induced Breakdown Spectroscopy (LIBS) in the Field of Quantitative Elemental Analysis[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(07): 2124-2131. |
|
|
|
|