光谱学与光谱分析 |
|
|
|
|
|
Long Optical Path Gas Detection Based on MEMS Infrared Light Source |
DU Bin-bin1,2, ZHANG Peng1,2, GAO Wen-hong1,2, SHI Yun-bo1,2, ZHU Lin-quan1,2 |
1. National Key Laboratory for Electronic Measurement Technology, North University of China, Taiyuan 030051, China 2. Key Laboratory of Instrumentation Science & Dynamic Measurement of Ministry of Education, North University of China, Taiyuan 030051, China |
|
|
Abstract According to the requirements of infrared gas sensor for the light source, a broad wavelength, high modulation frequency, low power consumption and small size MEMS infrared light source is chosen as the radiation source, whose performance meets the requirements of infrared sensing system for the light source greatly. However, the infrared light source with the lamberation radiation characteristics is a surface light source, which is still with a large numerical aperture after shaping. It is difficult to increase the detection sensitivity by using a traditional long optical gas cell in a MEMS infrared light source detection system. Based on the dual-wavelength single beam differential detection method, an integrating sphere as the gas cell for long optical path is designed, which is able to realize long optical path for high sensitivity gas detection. The physical dimension is deduced for the equivalent optical path according to the flux conservation principle in the process of light transmission, solving the calculation problem of equivalent optical path of the integrating sphere cell. Using FPGA control chip, the MEMS infrared light source is droved at high frequency modulation and the detector output signal is processed, which makes the external circuit design much simple and flexible. It turns out that 166.7 cm equivalent optical path and the minimum concentration of methane of 0.001×10-6 are achieved by the use of a 5 cm diameter integrating sphere in the research, improving the sensitivity of infrared detection system greatly.
|
Received: 2013-08-12
Accepted: 2013-11-20
|
|
Corresponding Authors:
DU Bin-bin
E-mail: dubinbin_nuc@163.com
|
|
[1] WU Fei-die, JI Xin-ming, WANG Jian-ye, et al(吴飞蝶, 纪新明, 王建业, 等). Transducer and Microsyetem Technologies(传感器与微系统), 2006, 25(5):78. [2] QIAN Kun, LI Fang-qiang, CHENG Mei-ying, et al(钱 昆, 李方强, 程美英, 等). Acta Optica Sinica(光学学报), 2010, 30(5):1455. [3] John U. White. Opt. Soc. Am.,1942, 32:285. [4] Herriott D, Kogelnik H, Kompfner R. Appl. Opt.,1964, 3:523. [5] Chernin S M,Barskaya E G. Appl. Opt.,1991, 30:51. [6] GUAN Cong, QU Yi(贯 丛, 曲 艺). Laser and Infrared(激光与红外), 2012, 42(1): 360. [7] JI Xin-ming, WU Fei-die, WANG Jian-ye, et al(纪新明, 吴飞碟, 王建业, 等). Optics and Precision Engineering(光学 精密工程), 2005, 13(2): 144. [8] Masiyano D,Hodgkinson J,Tatam R P. Applied Physics B, 2010, 100: 303. [9] HU Yu-xi, AN Lian-sheng(胡玉禧, 安连生). Applied Optics(应用光学). Hefei: University of Science and Technology of China Press(合肥: 中国科学技术大学出版社), 2006. 117. [10] Jane Hodgkinson, Dackson Masiyano, Ralph P Tatam. Applied Optics, 2009, 48(30): 5748. [11] WANG Ru-lin, WANG Yong-tao(王汝林, 王咏涛). Infrared Detection Technology(红外检测技术). Beijing: Chemical Industry Press(北京:化学工业出版社), 2006. 171.
|
[1] |
LI Zhen-gang1, 2, SI Gan-shang1, 2, NING Zhi-qiang1, 2, LIU Jia-xiang1, FANG Yong-hua1, 2*, CHENG Zhen1, 2, SI Bei-bei1, 2, YANG Chang-ping1, 2. Research on Long Optical Path and Resonant Carbon Dioxide Gas
Photoacoustic Sensor[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2023, 43(01): 43-49. |
[2] |
WANG Run-yu1, DONG Da-ming1,2, YE Song1*, JIAO Lei-zi1,2. Measurement of Volatile Compounds Released From Plastic Using[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2021, 41(10): 3039-3044. |
[3] |
JIN Hua-wei1, 2, 3, XIE Pin-hua1, 2, HU Ren-zhi1, 2*, LIU Wen-qing1, 2, LI Zhi-yan1, 2, CHEN Hao1, 2, HUANG Chong-chong1, 2. Study on Photo-Acoustic Spectrum Detection Technology of Respiratory Dust Absorption Coefficient[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2019, 39(07): 1993-1998. |
[4] |
LÜ Mo1, WANG Yi-ding1*, CHEN Chen2*. Development of Mid-Infrared Trace-CO Detector with Long-Path Differential Optical Absorption Spectroscopy (LP-DOAS)[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2017, 37(07): 2278-2282. |
[5] |
GUO Jin-jia, YANG De-wang, LIU Chun-hao . Raman Signal Enhancement for Gas Detection Using a Hollow Core Optical Fiber[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2016, 36(01): 96-98. |
[6] |
FAN Jie, CHEN Xiao*, HUANG Qi-feng, ZHOU Yu, CHEN Gang . Study on High Accuracy Detection of Multi-Component Gas in Oil-Immerse Power Transformer[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2013, 33(12): 3326-3329. |
[7] |
SUN Zhao-hua1,2, CAO Wen-xi1, ZHAO Jun1,2, LI Cai1, ZHOU Wen1,2. Construction and Test of Long Pathlength Automated Analyzer of Trace Nutrients in Seawater[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2008, 28(12): 3000-3003. |
[8] |
XU Liang,LIU Jian-guo,GAO Min-guang,LU Yi-huai,WEI Xiu-li,ZHANG Tian-shu,ZHU Jun,CHEN Jun . Application of Long Open Path FTIR System in Ambient Air Monitoring[J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2007, 27(03): 448-451. |
[9] |
LIU Zhao-rong,HU Di . Study on the Gas-Phase Reaction of α-Pinene with Ozone by LP-FTIR [J]. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2004, 24(07): 813-816. |
|
|
|
|