1. College of Mechanical and Electrical Engineering, Shihezi University, Shihezi 832003, China 2. Food College, Shihezi University, Shihezi 832003, China
Abstract：In the process of spectral modeling, spectral extraction of characteristic bands with different variable screening algorithms is an important step for improving the model effects. Total viable count of cooling mutton under vacuum packing condition was chosen as the research index in this paper, while the influence of 2 variable screening algorithms on its hyperspectral PLS model effects was compared. Mutton muscle spectra of Regions of interest (ROIs) were extracted and preprocessed. Subsequently, Genetic Algorithm (GA) and Competitive Adaptive Reweighted Sampling (CARS) were applied to extract characteristic bands from preprocessed spectra at full band range of 473～1 000 nm. Model effects of GA-PLS, CARS-PLS and W-PLS with corresponding bands selection were contrasted and analyzed. The results indicated that both model effects of GA-PLS, CARS-PLS were better than that of W-PLS, and CARS-PLS model effect was optimal. As for the CARS-PLS model, the determination coefficient (R2c) and root mean square error (RMSEC) of calibration set was 0.96 and 0.29, and the determination coefficient (R2cv) and root mean square error (RMSECV) of leave-one-out cross validation was 0.92 and 0.46, respectively. Meanwhile, the determination coefficient (R2p), root mean square error of prediction (RMSEP) and the ratio of standard deviation to standard error of prediction (RPD) of prediction set was 0.92 and 0.47 and 3.58, respectively. Therefore, hyperspectral imaging (HSI) technology combined with CARS-PLS can achieve quick, non-destructive and accurate detection of mutton total viable count.
[1] LING Xiu-mei, CHEN Li-ling, ZHANG Min, et al(凌秀梅, 陈礼玲, 张 敏, 等). Food Science(食品科学), 2013, 34(20): 246. [2] NING Chu-guang, YANG Yang, WU Xiao-yong(宁初光, 杨 洋, 吴小勇). Modern Food Science and Technology(现代食品科技), 2012, 28(2): 237. [3] Naganathan G K, Grimes L M, Subbiah J, et al. Computers and Electronics in Agriculture, 2008, 64(2): 225. [4] Qiao J, Ngadi M O, Wang N, et al. Journal of Food Engineering, 2007, 83(1): 10. [5] Elmasry G, Sun D W, Allen P. Journal of Food Engineering, 2012, 110(1): 127. [6] GUO Zhong-hua, ZHENG Cai-ying, JIN Ling(郭中华, 郑彩英, 金 灵). Science and Technology of Food Industry(食品工业科技), 2014, 35(20): 66, 81. [7] ZHU Xi-cun, ZHAO Geng-xing, WANG Rui-yan, et al(朱西存, 赵庚星, 王瑞燕, 等). Scientia Agricultura Sinica(中国农业科学), 2010, 43(6): 1189. [8] YAO Fu-qi, ZHANG Zhen-hua, YANG Run-ya, et al(姚付启, 张振华, 杨润亚, 等). Science of Surveying and Mapping(测绘科学), 2010, 35(1): 109. [9] MA Shi-bang, TANG Xiu-ying, XU Yang, et al(马世榜, 汤修映, 徐 杨, 等). Transactions of the Chinese Society of Agricultural Engineering(农业工程学报), 2012, 28(18): 263. [10] Li H, Liang Y, Xu Q, et al. Analytica Chimica Acta, 2009, 648(1): 77. [11] Huang L, Zhao J, Chen Q, et al. Food Research International, 2013, 54(1): 821. [12] Wang W, Li C, Tollner E W, et al. Journal of Food Engineering, 2012, 109(1): 38. [13] Chen Q, Zhang Y, Zhao J, et al. Analytical Methods, 2013, 5(22): 6382. [14] Malley D F, McClure C, Martin P D, et al. Communications in Soil Science and Plant Analysis, 2005, 36(4-6): 455. [15] LIU Jing, GUAN Xiao(刘 静, 管 骁). Journal of Jiangsu University(江苏大学学报), 2012, 33(3): 288，321. [16] DUAN Hong-wei, ZHU Rong-guang, WANG Long, et al(段宏伟, 朱荣光, 王 龙, 等). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2016, 36(4): 1145. [17] Peng Y, Zhang J, Wang W, et al. Journal of Food Engineering, 2011, 102(2): 163. [18] ElMasry G, Wang N, Vigneault C, et al. LWT-Food Science and Technology, 2008, 41(2): 337. [19] Liu Y, Lyon B G, Windham W R, et al. Meat Science, 2003, 65(3): 1107.
