Study on the Rapid Evaluation of Total Volatile Basic Nitrogen (TVB-N) of Mutton by Hyperspectral Imaging Technique
ZHU Rong-guang1, YAO Xue-dong1, DUAN Hong-wei1, MA Ben-xue1, TANG Ming-xiang2
1. College of Mechanical and Electrical Engineering, Shihezi University, Shihezi 832003, China 2. Food College, Shihezi University, Shihezi 832003, China
Abstract：Total Volatile Basic Nitrogen (TVB-N) was usually taken as the physicochemical reference value to evaluate the mutton freshness. In order to explore the feasibility of hyperspectral (HSI) imaging technique to detect mutton freshness, 71 representative mutton samples were collected and scanned using a diffuse reflectance hyperspectral imaging (HSI) system in the Visible-Near infrared (NIR) spectral region (400～1 000 nm), and the chemical values of TVB-N content were determined using the semimicro Kjeldahl method according to the modified Chinese national standard. The representative spectra of mutton samples were extracted and obtained after selection of the region of interests (ROIs). The samples of calibration set and prediction set were divided at the ratio of 3∶1 according to the content gradient method. Optimum HSI calibration models of the mutton (TVB-N) were established and evaluated by comparing different spectral preprocessing methods and modeling methods, which included Stepwise Multiple Linear Regression (SMLR), Partial Least Squares Regression (PLSR) and Principal Component Regression (PCR) methods. The results are that through the utilization of Multiplicative Scatter Correction (MSC), first derivative, Savitzky-Golay (S-G) smoothing and mean-centering together, both PLSR and PCR were able to achieve quantitative detection of mutton TVB-N. As for the PLSR model of mutton TVB-N established, the spectral pretreatment methods chosen included MSC, first derivative, S-G (15,2) smoothing and mean-centering, and the latent variables (LVs) number used was 11. As for the calibration set of PLSR model of mutton TVB-N, the correlation coefficient (r) and root mean square error of calibration (RMSEC) were 0.92 and 3.00 mg·(100 g)-1, respectively. As for the prediction set of PLSR model of mutton TVB-N, the correlation coefficient (r), Root Mean Square Error of Prediction (RMSEP), and ratio of standard deviation to standard error of prediction (RPD) were 0.92, 3.46 mg·(100 g)-1 and 2.35, respectively. The study demonstrated that the rapid and accurate analysis of TVB-N, the key freshness attribute, could be implemented by using the hyperspectral imaging (HSI) technique. The study provides the basis for further rapid and non-destructive detection of other mutton freshness attributes by using the hyperspectral imaging (HSI) technique, the improvement of current modeling effect of TVB-N content and the application involved of the technique in the practical production.
朱荣光1，姚雪东1，段宏伟1，马本学1，唐明翔2 . 羊肉挥发性盐基氮的高光谱图像快速检测研究 [J]. 光谱学与光谱分析, 2016, 36(03): 806-810.
ZHU Rong-guang1, YAO Xue-dong1, DUAN Hong-wei1, MA Ben-xue1, TANG Ming-xiang2 . Study on the Rapid Evaluation of Total Volatile Basic Nitrogen (TVB-N) of Mutton by Hyperspectral Imaging Technique . SPECTROSCOPY AND SPECTRAL ANALYSIS, 2016, 36(03): 806-810.
[1] National Standardization Management Committee of China(中国国家标准化管理委员会). GB/T 5009.44—2003. Method for Analysis of Hygienic Standard of Meat and Meat Products(肉和肉制品卫生标准的分析方法). Beijing: Standards Press of China(北京：中国标准出版社), 2003. [2] National Standardization Management Committee of China(中国国家标准化管理委员会). GB 2707—2005. Hygienic Standard for Fresh(Frozen) Meat of Livestock(鲜(冻)畜肉卫生标准). Beijing: Standards Press of China(北京：中国标准出版社), 2005. [3] ZHANG Lei-lei, LI Yong-yu, PENG Yan-kun, et al(张雷蕾，李永玉，彭彦昆, 等). Transactions of the Chinese Society of Agricultural Engineering(农业工程学报), 2012, 28(7): 254. [4] CAI Jian-rong, WAN Xin-min, CHEN Quan-sheng(蔡建荣，万新民，陈全胜). Acta Optica Sinica(光学学报), 2009, 29(10): 2808. [5] ZHU Rong-guang, MA Ben-xue, FU Wei, et al(朱荣光，马本学，付 威，等). Journal of Agricultural Mechanization Research(农机化研究), 2013, 35(1): 14. [6] Huang L, Zhao J W, Chen Q S, et al. Food Chemistry, 2014, 145: 228. [7] Qiao J, Ngadi M O, Wang N, et al. Journal of Food Engineering, 2007, 83: 10. [8] Douglas F, Barbin D F, ElMasry G, et al. Analytica Chimica Acta, 2012, 719: 30. [9] ElMasry G, Sun D W, Allen P, et al. Journal of Food Engineering, 2012, 110: 127. [10] Kamruzzamana M, ElMasrya G, Sun D W, et al. Analytica Chimica Acta, 2012, 714: 57. [11] Peng Y K, Zhang J, Wang W, et al. Journal of Food Engineering, 2011, 102: 163. [12] Chen Q S, Zhang Y H, Zhao J W, et al. Analytical Methods, 2013, 22(5): 6382. [13] Malley D F, McClure C, Martin P D, et al. Communications in Soil Science and Plant Analysis, 2005, 36: 455. [14] ZHU Rong-guang, HAN Lu-jia, YANG Zeng-ling, et al(朱荣光，韩鲁佳，杨增玲, 等). Journal of Infrared and Millimeter Waves(红外与毫米波学报), 2006, 25(4): 267. [15] Burns D A, Ciurczak E W. Handbook of near infrared analysis (3rd edition). New York, Boca Raton, 2008.
