Abstract:Nondestructive fruit quality assessment in packing houses can be carried out using near infrared (NIR) spectroscopy. However, in industrial process, some experimental conditions (e.g. temperature, fruit variety) cannot be strictly controlled and their changes would reduce the robustness of the NIR-based models. In the present paper, a total of 100 honey fruits from two super markets were used as experimental materials. Fifty honey fruits were stored at room temperature and the other fifty samples were stored at 0-4 ℃. NIR diffuse reflectance spectra of the honey peaches were measured in the spectral range of 4 000-12 500 cm-1 using InGaAs detector. After outlier diagnosis using leverage values and Dixon test and spectra data pretreatment with Norris derivative filter (segment length: 5, gap: 5), partial least square (PLS) regression with standard normal variate (SNV) transformation and stepwise multilinear regression (SMLR) with multiplicative scatter correction (MSV) were used to establish calibration models based on first derivative spectra. Comparing the two calibration methods of PLS and SMLR, the performances of the models developed by SMLR were found much better than that by PLS method. The best results for PLS models were: correlation coefficient of calibration (RC)=0.965, root mean square errors of calibration (RMSEC)=0.301° Brix,correlation coefficient of cross-validation (RCV)=0.812, root mean square errors of cross-validation (RMSECV)=0.67° Brix and ratio of standard deviation to root mean square errors of cross-validation (RPD)=1.72, which were slightly worse than those for SMLR: RC=0.929, RMSEC=0.424° Brix of calibration and RCV=0.887, RMSECV=0.532° Brix of cross-validation and RPD=2.16. The RPD values for SMLR models in three different spectral regions 4 290-7 817, 7 817-10 725 and 4 290-10 725 cm-1 were: 1.97, 1.89 and 2.16, respectively. The performance of the model developed by SMLR in the 4 290-7 817 cm-1 region was much better than that in the 7 817-10 725 cm-1 region. The results indicated that the SMLR method could develop a good calibration model by selecting wavelengths insensitive to temperature and NIR spectra could be used for sugar content prediction of fruit samples with varied temperature when developing a global robust calibration model to cover the temperature range.
徐惠荣,汪辉君,黄康,应义斌*,杨诚,钱豪,胡俊. PLS和SMLR建模方法在水蜜桃糖度无损检测中的比较研究[J]. 光谱学与光谱分析, 2008, 28(11): 2523-2526.
XU Hui-rong, WANG Hui-jun, HUANG Kang, YING Yi-bin*, YANG Cheng, QIAN Hao, HU Jun. Comparison of PLS and SMLR for Nondestructive Determination of Sugar Content in Honey Peach Using NIRS. SPECTROSCOPY AND SPECTRAL ANALYSIS, 2008, 28(11): 2523-2526.
[1] YU Hai-yan, YING Yi-bin, LIU Yan-de(于海燕, 应义斌, 刘燕德). Transaction of the Chinese Society of Agricultural Engineering(农业工程学报), 2005, 21(11): 160. [2] Golic M, Walsh K B. Analytica Chimica Acta, 2006, 555: 286. [3] Peirs A, Scheerlinck N, Nicolai B M. Postharvest Biology and Technology, 2003, 30: 233. [4] Hernández Sánchez N, Lurol S, Roger J M, et al. Journal of Near Infrared Spectroscopy, 2003, 11: 97. [5] LIU Jian-xue, WU Shou-yi, FANG Ru-ming(刘建学, 吴守一, 方如明). Transaction of the Chinese Society of Agricultural Engineering(农业工程学报), 2000, 16(3): 94. [6] LIAN Wen-liu, WU Ming-jian, SUN Xian-jun, et al(练文柳, 吴名剑, 孙贤军, 等). Tobacco Science & Technology(烟草科技), 2005, (2): 19. [7] YU Hai-yan, YING Yi-bin, XIE Li-juan, et al(于海燕, 应义斌, 谢丽娟, 等). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2007, 27(6): 1118. [8] WU Jing-zhu, WANG Yi-ming, ZHANG Xiao-chao, et al(吴静珠, 王一鸣, 张小超, 等). Modern Scientific Instruments(现代科学仪器), 2006, (1): 69. [9] YANG Hu-sheng,Griffiths P R,Tate J D. Analytica Chimica Acta,2003,489(2):125. [10] LU Wan-zhen, YUAN Hong-fu,XU Guang-tong,et al(陆婉珍,袁洪福,徐广通,等). Modern Near Infrared Spectroscopy Analytical Technology(现代近红外光谱分析技术). Beijing:China Petrochemical Press(北京:中国石化出版社),2000. [11] MIN Shun-geng, LI Ning, ZHANG Ming-xiang(闵顺耕,李 宁,张明祥). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2004,24(10):1205. [12] LIU Rong,CHEN Wen-liang,XU Ke-xin, et al(刘 蓉, 陈文亮, 徐可欣, 等). Spectroscopy and Spectral Analysis(光谱学与光谱分析), 2005, 25(2): 207. [13] Karoui R, Mouazen A M, Dufour E, et al. International Dairy Journal, 2006, 16: 1211. [14] Mouazen A M, De Baedemaeker J, Ramon H. Soil and Tillage Research, 2005, 80(1-2): 171.